Abstract
This study aimed to assess the efficacy of a heat-inactivated Mycobacterium caprae (HIMC) vaccine in goats experimentally challenged with the same strain of M. caprae. Twenty-one goats were divided into three groups of seven: vaccinated with heat-inactivated Mycobacterium bovis (HIMB), with HIMC and unvaccinated. At 7 weeks post-vaccination all animals were endobronchially challenged with M. caprae. Blood samples were collected for immunological assays and clinical signs were recorded throughout the experiment. All goats were euthanized at 9 weeks post-challenge. Gross pathological examination, analysis of lung pathology using computed tomography, and bacterial load quantification in pulmonary lymph nodes (LN) by qPCR were carried out. Only HIMC vaccinated goats showed a significant reduction of lung lesions volume and mycobacterial DNA load in LN compared to unvaccinated controls. Both vaccinated groups showed also a significant reduction of the other pathological parameters, an improved clinical outcome and a higher proportion of IFN-γ-producing central memory T cells after vaccination. The results indicated that homologous vaccination of goats with HIMC induced enhanced protection against M. caprae challenge by reducing lung pathology and bacterial load compared to the heterologous vaccine (HIMB). Further large-scale trials are necessary to assess the efficacy of autovaccines under field conditions.
Similar content being viewed by others
Introduction
Tuberculosis (TB) is an infectious disease caused by Mycobacterium tuberculosis complex bacteria that affects humans and a wide range of domestic animals and wildlife. Animal TB is a zoonotic disease that still represents an important public health issue, particularly in middle and low-income regions where it is estimated to cause up to 10% of human TB cases in some countries1. Hence, the control and eradication of TB requires a One Health approach.
Domestic goats are particularly susceptible to this disease2, which is mainly caused by Mycobacterium caprae and Mycobacterium bovis3. The goat population in Spain was approximately 2.7 million in 2020 FAOSTAT, accessed on 12/07/2022), being the second largest census of the European Union after Greece. Goat herds are not yet subjected to a National eradication program, except for those epidemiologically related with cattle4. Caprine TB causes relevant economic losses on the goat industry in endemic areas3,5,6 and infected goats pose a risk of infection to other animal species such as cattle or wildlife, and humans7.
Alternative approaches to control livestock TB, such as test-and-segregate or vaccination are being prospected when strict test-and-cull strategies are unfeasible for logistic, economic or cultural reasons8,9,10,11. In some European regions, vaccination can be an ancillary tool for the control of TB in non-bovine domestic and wild animals in areas with a high burden of TB, particularly in those where multi-host maintenance communities have been identified12, hampering the success of bovine TB eradication campaigns.
The safety, immunogenicity and efficacy of M. bovis Bacillus Calmette-Guérin (BCG), the only vaccine against TB licensed so far for humans, and badgers in the UK, has been evaluated in goats in experimental and natural infection settings9,13,14,15. However, BCG stability in environmental conditions could be limited and an eventual transmission to other livestock or wildlife species cannot be ruled out16,17. Therefore, inactivated mycobacterial vaccines have been also assessed in experimentally18 and naturally19,20 infected goats.
This study was conceived as an autovaccine proof-of-concept to assess the efficacy of a heat-inactivated M. caprae (HIMC) vaccine in goats experimentally challenged with the same strain of M. caprae used to prepare the vaccine, and to compare it to goats vaccinated with a previously characterized heterologous vaccine based on heat-inactivated M. bovis (HIMB)18.
Results
Cell-mediated immune responses after vaccination and challenge
The mean antigen-specific whole blood IFN-γ responses before and after challenge for each treatment group are depicted in Fig. 1. A mild increase of IFN-γ responses to PPD-B and P22 were detected in the HIMC vaccinated group at seven weeks after vaccination (Week 0, Fig. 1a,b) although without significant difference when compared to other groups. After challenge, the mean levels of IFN-γ began to increase in the three experimental groups. At week 5, PPD-B specific IFN-γ responses were significantly higher in unvaccinated animals compared to HIMC and HIMB groups (P < 0.05 and P < 0.01, respectively Fig. 1a). At the same time point, both vaccinated groups also showed lower P22 specific IFN-γ responses compared to the unvaccinated group although they were only statistically significant in the HIMB vaccinated group (P < 0.01, Fig. 1b). None of the vaccinated animals showed detectable IFN-γ responses to E/C after vaccination (Fig. 1c). After challenge, the vaccinated groups also showed lower E/C-specific IFN-γ responses than the control group, being statistically significant at weeks 3 (P < 0.05) and 5 (P > 0.05 and P < 0.01 in HIMC and HIMB groups, respectively).
Analysis of IFN-γ-producing cell subsets was performed by flow cytometry at seven weeks post-vaccination (Week 0) using PBMC isolated from the seven HIMB vaccinated, 5 HIMC vaccinated and 5 unvaccinated animals (4 animals did not show sufficient viable PMBC for the assay). Gating strategy is shown in Fig. 2a–d. Both vaccinated groups showed statistically significant higher frequencies of IFN-γ-producing CD4 lymphocytes with a central memory phenotype (C45RO+ CD62L+) compared to unvaccinated animals (HIMB: P < 0.01, HIMC: P < 0.05, Fig. 2e).
Finally, specific production of multiple cytokines after stimulation of whole blood with PPD-B and E/C was analysed at week 0 (before challenge) and at weeks 5 and 9 post-challenge. Results of cytokine production profiles relative to maximum value of each cytokine are presented in Fig. 3. Before challenge (week 0, 7 weeks post-vaccination), both vaccinated groups showed a slightly higher PPD-B-specific proinflammatory (IFN-γ, IL-17A and IL-6) responses compared to the control group (Fig. 3a). Productions of IL-1β in both PPD-B and E/C stimulated blood samples were higher in the HIMB group (P < 0.001).
At five weeks after challenge, unvaccinated animals experienced an increase of both proinflammatory cytokines (IFN-γ, IL-17A, IL-1β) and IL-10 production. However, overall cytokine responses decreased in the control group at week 9, when HIMC vaccinated goats showed higher E/C-specific levels of IL-6 compared to other groups (P < 0.05, Fig. 3b), and HIMB group showed significantly higher levels of IL-1b to PPD-B (P < 0.05, Fig. 3a). At this time point, vaccinated groups also showed a mild increase of both E/C-specific IFN-γ and anti-inflammatory responses (IL-10 and IL-4 in HIMC and HIMB groups, respectively), although not statistically significant (Fig. 3b). No statistically significant differences in TNFα production were observed among groups throughout the experiment.
Humoral responses after vaccination and challenge
IgG levels to the antigen MPB83 (Fig. 4a) and the P22 antigenic complex (Fig. 4b) were measured by two ELISAs throughout the study showing similar kinetics at 3 and 7 weeks postvaccination (p.v). HIMB-vaccinated group showed an increase of IgG levels to both antigens compared to HIMC and control groups (Fig. 4), although this increase was only statistically significant in the P22 ELISA (P < 0.05, Fig. 4b). Only two HIMC vaccinated animals showed mild IgG responses after vaccination. By contrast, the IgG responses to both antigens increased at 3 weeks post-challenge in both vaccinated groups compared to the control group, although it was only statistically significant in the P22 ELISA (P < 0.01 and P < 0.05, for HIMB and HIMC groups, respectively), that showed a slightly delayed seroconversion. From week 5 onwards, no significant differences between groups were observed (Fig. 4).
Clinical signs and body condition after challenge
Animals were observed for clinical signs of TB after M. caprae challenge. Results are summarized in Table 1. Mild clinical signs appeared in most non-vaccinated animals at week 3 and evolved to severe clinical signs in all animals at week 7 (two of them were humanely euthanized because end point criteria were reached). Only a few vaccinated animals showed mild clinical signs at week 3 (one of the HIMC and two of the HIMB groups). At the end of the experiment almost all animals developed TB clinical signs. The most observed were cough, dyspnoea, eye discharge, enlarged lymph nodes, runny nose and anorexia.
Rectal temperature and body weight were measured weekly after challenge (Fig. 5). The mean rectal temperature of the vaccinated groups was significantly lower than the control group from week 2 onwards (P < 0.05, Fig. 5a). No significant differences were observed between vaccinated groups. The mean body weight gain was significantly higher in vaccinated groups compared to the control group from week 3 onwards (P < 0.05, Fig. 5b). At the end of the experiment, the mean cumulative weight increase of the control group was 2.3 kg (− 0.9 to 5.4, 95% CI), significantly lower (P < 0.05) than the vaccinated groups (HIMB: 6.1 kg, 95% CI 5–7.7; HIMC: 7.0 kg, 95% CI 1.6–12.4). Again, no statistically significant differences were observed between HIMB and HIMC groups throughout the experiment.
Post-mortem findings
All goats showed TB lung lesions at necropsy. The assessment of lung lesions using CT is shown in Fig. 6. HIMC vaccinated group showed lower median values of the lung lesions volumes (78 cm3, 95% CI: 33–263) compared to the control group (155 cm3, 95% CI: 101–390; P < 0.05), and HIMB vaccinated group (151 cm3, 95% CI: 38–247; yet not statistically significant, Fig. 6d). Vaccinated groups showed lower intrapulmonary TB dissemination assessed by mean number of affected lobes (HIMC: 4.0, 95% CI 2.6–5.4, P < 0.01; HIMB: 4.1, 95% CI 2.5–5.8, P < 0.05) compared to the control group (6.3, 95% CI 5.1–7.4). Five out of seven unvaccinated animals showed TB lesions in the seven lung lobes whereas 6/7 HIMC and 4/7 HIMB vaccinated animals showed four or less lung lobes affected (Fig. 6e). In addition, vaccinated groups showed significantly lower median values of lung mineralization volumes (HIMC: 3.6 cm3, 95% CI: 1.8–23.4; HIMB: 6.8 cm3, 95% CI 0.8–23.7) compared to the control group (18.4 cm3, 95% CI 2.6–84.5, P < 0.05, Fig. 6f), and lower mineralization volume ratios of lung lesions (HIMB: 5%, 95% CI 2–12, P < 0.05; HIMC: 7%, 95% CI 3–27; Control: 11%, 95% CI 2–37; Fig. 6g).
In pulmonary LN, the median of TB lesions volumes was also significantly higher in the unvaccinated group (51.2 cm3, 33.6–119.2, 95% CI) compared to HIMB (23.7 cm3, 0.3–46.2, 95% CI; P < 0.01) and HIMC (25.6 cm3, 4.7–123.8, 95% CI; P < 0.05) groups (Fig. 7a). The bacterial DNA load in pulmonary LN, as estimated by qPCR, was significantly lower in HIMC vaccinated animals (P < 0.05) and slightly lower (but not statistically significant) in HIMB vaccinated animals compared to the control group (Fig. 7b).
With regard to extrapulmonary TB, the control group was the only one with all animals showing extrapulmonary lesions, a proportion significantly higher to that found in vaccinated groups (4/7 each, P < 0.05). A summary of extrapulmonary lesions found in each treatment group and their location is shown in Table 2.
Cross-sectional analysis: biomarkers of vaccine efficacy
To assess immunological markers as predictors of vaccination outcome, the antigen-specific IFN-γ-producing CD4 central memory T (TCM) cell subsets (CD45RO+ CD62L+) obtained by flow cytometry in each vaccinated animal (N = 12) were correlated with clinical, pathological and bacteriological results of the same animal (Table 3). Results showed significant inverse correlations of TCM % with volume of lung lesions and lesion volume / lung volume ratio, whereas no correlation was observed with LN lesions and bacterial DNA load in LN. Regarding clinical signs, body weight increase after challenge (mean Kg at week 9 minus mean Kg at week 0) showed significant direct correlation with TCM % and mean rectal temperature obtained at the temperature peak time point (week 3) showed significant inverse correlation with TCM %.
Discussion
Inactivated mycobacterial vaccines can be adapted ad hoc to field conditions by generating autovaccines with the same strains circulating in the herd or in a specific outbreak area. This is the first proof-of-concept study to evaluate the efficacy of a heat-inactivated autovaccine against M. caprae infection in goats.
Nowadays, there is a certain degree of background regarding the inactivated vaccine candidate based on M. bovis (HIMB), that have been reported to protect goats against TB in laboratory and field conditions18,20, as well as cattle21, wild boar22,23, red deer24, badgers25 and wild pigs26. HIMB represents an interesting alternative to live-attenuated BCG vaccine since the deployment logistics are simpler and the strain survival is not required27. In the present study, the gross pathology and bacteriological results, as well as the clinical follow-up after experimental challenge with M. caprae, ratified that MTBC-inactivated vaccines conferred protection when compared to unvaccinated animals.
Moreover, the HIMC group, vaccinated with the M. caprae strain homologous to the challenge strain (autovaccine proof-of-concept), showed slightly better protection against pulmonary TB compared to the group vaccinated with the heterologous vaccine (HIMB), with lower volume of lung lesions and animals showing lower number of affected lung lobes. In addition, the HIMC vaccinated group presented significantly lower bacterial DNA load in pulmonary LN, even when considering that one of the animals vaccinated with HIMC showed a huge amount of bacterial load (over 106 CFU equivalents, very much higher than any unvaccinated goat). This animal also showed very high pathological extension compared to the rest of the group (being an outlier for all parameters). Intriguingly, this goat did not show detectable immune responses (neither to ELISA nor IGRA) after vaccination. Even though an unnoticed incorrect administration of the vaccine cannot be ruled out, this animal could have been immunocompromised at the vaccination time point, and thus would have not been properly immunized.
Interestingly, vaccinated groups not only did show a reduced volume of lung lesions and lung mineralization compared to the control group, but also showed lower volume ratio of mineralization within the lung lesions, suggesting that the lung pathology was in earlier/more contained developmental stages compared to unvaccinated animals according to criteria previously described for M. bovis infected cattle using histopathology28. This approach defined four granuloma developmental stages according to different parameters such as the degree of mineralization. Using these criteria, cattle vaccinated with BCG or BCG-prime / heterologous boost regimes also showed lower proportion of lung lesions in advanced developmental stages29,30.
Vaccination also reduced the incidence and spread of extrapulmonary TB as previously described in BCG or HIMB vaccinated goats18. All unvaccinated animals showed TB lesions in the spleen and, in this control group there was also a higher number of animals with lesions in hepatic and mesenteric LN, indicative of a reduced lymphohematogenous dissemination of mycobacteria in both vaccinated groups.
Comparisons of clinical parameters, particularly the body weight increase and rectal temperature kinetics, were very consistent with post-mortem results. The body weight change and the rectal temperature at 3 to 5 weeks post-challenge are useful indicators of vaccination outcome as previously demonstrated in experimental trials conducted in goats and sheep18,31,32, and should be considered as valuable parameters in experiments to assess the efficacy of vaccines and treatments against TB.
Even though the administration of inactivated vaccines induced detectable ex vivo IFN-γ responses to PPD-B and P22 using IGRAs, in a number of animals, no responses were detected when using an E/C protein cocktail after vaccination and before challenge. This result agrees to previously reported in HIMB parenterally vaccinated goats18. In addition, the intensity of E/C-specific IFN-γ responses after challenge were equivalent to that induced by PPD-B and P22, indicating that this cocktail, initially developed for TB diagnosis and compatible with BCG vaccination, could be also suitable as a DIVA reagent for IGRA tests after administration of MTBC inactivated vaccine.
Unvaccinated animals showed higher IFN-γ levels measured by the IGRAs after challenge compared to vaccinated ones, reaching a peak response at five weeks post-challenge. This trend was confirmed by increased proinflammatory responses in unvaccinated animals measured by the multi-cytokine assays performed at 5 weeks post challenge. At this time point, unvaccinated group showed higher antigen-specific IFN-γ, IL-17A and IL-1β levels compared to vaccinated groups. This multi-cytokine proinflammatory pattern has also been described in buffalos infected with M. bovis33 that showed increased proinflammatory cytokines and chemokines (IP-10, IFN-γ, IL-6, IL-17A, MIP-1β, MIP-1α and MCP-1) in whole blood stimulated with the E/C whereas anti-inflammatory cytokines (IL-4 and IL-10) remained in basal levels. On the contrary, in the present experiment unvaccinated goats also showed increased IL-10 responses at 5 weeks post challenge. The anti-inflammatory effect induced by this increase of IL-10 levels in unvaccinated goats could be associated to the subsequent decrease of proinflammatory responses (to both IGRA and multi-cytokine assays at week 9 post vaccination), while vaccinated animals maintained moderate levels throughout the experiment.
In this study, the contained IFN-γ responses in vaccinated animals agreed with a more favourable disease outcome. However, whole blood ex vivo IFN-γ responses in vaccine trials should be interpreted with caution since previous studies reported that BCG vaccinated goats showed reduced34, similar35 or even higher18 antigen-specific IFN-γ responses after M. caprae challenge compared to unvaccinated controls.
Therefore, more accurate immunomarkers are required as predictors of vaccine efficacy and correlators of disease progression. The most useful immunological biomarkers to predict the vaccine efficacy are those that can be measured before the infection/exposure of animals to mycobacteria. With this purpose, as well as to estimate the duration of the vaccine-induced immunity, we assessed the proportion of antigen-specific IFN-γ-producing TCM subsets, based on the expression of CD45RO and CD62L receptors36.
Individual PPD-B-specific IFN-γ-producing TCM % correlated with favorable disease outcome parameters, namely, reduced lung lesions, higher body weight gain, and lower peak of rectal temperature, suggesting that this immunological parameter can be a useful biomarker to infer the vaccine-induced protective immunity. Similarly, proliferation of antigen-specific memory T-cells determined by cultured IFN-γ ELISPOT were also inversely associated to the pathology degree in vaccinated cattle and goats35,37.
On the other hand, the expansion of cells with a TCM phenotype elicited by vaccination is suggestive of long-term immunity as reported for mice and humans36,38. Nevertheless, the duration of the vaccine-induced immunity cannot be properly estimated in merely a seven-week period after vaccination and longer studies are required to confirm the results. In long-term trials, a wane of BCG-induced ex vivo IFN-γ response has been observed in goats from 24 weeks p.v. onwards9 and, approximately one year after vaccination, the proportion of PPD-B-specific IFN-γ-producing T-memory cells (CD45RO+) was similar to that of unvaccinated goats, although it increased significantly when measured three weeks after revaccination32.
Finally, serological results confirm the ability of inactivated vaccines, particularly HIMB, to induce MTBC-specific antibody responses18 and, as such, the specificity of the serology will be compromised as a TB diagnostic tool in vaccinated animals39. Surprisingly, the seroconversion was less frequent and less intense (when it occurred) after HIMC vaccination. A lower expression of MPB83 (also a major component of P22 reagent) or a lower exposure of this protein in the M. caprae cell surface compared to M. bovis might be explanatory factors of this different antibody-response patterns, although the underlaying mechanisms were not investigated and further comprehensive and focused studies should be carried out to confirm this hypothesis.
Given that autovaccines may have advantages, particularly from the regulatory point of view, and that heat-inactivated mycobacterial vaccines are easy to produce, the results of this proof-of concept study encourage to conduct further autovaccine field trials in natural infection settings to validate this vaccination strategy that can contribute to control TB in goats in high-prevalent scenarios when test-and-cull is unfeasible.
Methods
Animals, vaccination schedule and experimental infection
Twenty-one female Pyrenean breed goats of approximately 2 months of age, from an officially TB-free herd located at the Catalan Pyrenees (Spain) were divided into 3 experimental groups of 7 animals each: Unvaccinated control group, group vaccinated with heat-inactivated M. bovis (HIMB) and group vaccinated with heat-inactivated M. caprae (HIMC).
Inactivated vaccines were produced at NEIKER (Basque Country, Spain) and prepared as previously described22. Briefly, HIMB was prepared from a M. bovis field strain (SB0339,www.Mbovis.org) isolated from a naturally infected wild boar, while HIMC was produced by the same procedure using a M. caprae field strain (SB0157, www.Mbovis.org) isolated from a tuberculous sheep in Catalonia40. Both field strains were sub-cultured in Middlebrook 7H9 broth (BD Diagnostics, USA) enriched with Oleic acid-Albumin-Dextrose-Catalase (OADC) for 3 weeks approximately and subsequently washed, tittered and inactivated as previously described18. Inactivated mycobacterial suspensions were oil-adjuvanted with Montanide ISA 61 VG (Seppic, Paris, France) as indicated by the manufacturer. Final concentration of vaccines was approximately 5 × 107 inactivated CFU/ml. All animals were subcutaneously vaccinated (on the right scapula) with 1 ml of HIMB or HIMC.
Six weeks after vaccination, all experimental animals were transferred to the Biosafety Level-3 (BSL-3) facility of IRTA-CReSA (Catalonia, Spain) and were housed in two experimental boxes with 3–4–4 and 4–3–3 animals from Control, HIMB and HIMC groups in each box, respectively. Animals were fed with hay, alfalfa, mineral salt and maintained with water ad libitum throughout the experiment.
After a week of acclimatation, the animals were sedated with an intramuscular administration of acepromazine maleate (0.05 mg/kg) and butorphanol (0.2 mg/kg) and subsequently anesthetized with the intravenous administration of propophol (5 mg/kg) and midazolam (0.2 mg/kg). Afterwards, the animals were endonbronchially challenged as previously described2 with 0.5 ml of an approximately 2 × 103 CFU/ml suspension of the same M. caprae strain used to prepare the HIMC vaccine.
After challenge, the animals were daily monitored for clinical signs. Rectal temperature and body weight were measured every week. Animals were bled at weeks -7 (vaccination time point), -3, 0 (challenge time point), 3, 5, 7 and 9 (end point) for immunological assays.
The experimental design and the experiments were conducted following the recommendations in ARRIVE guidelines (https://arriveguidelines.org/).
Ethics statement
All procedures involving experimental animals carried out during the study followed the recommendations in the ARRIVE guidelines (https://arriveguidelines.org/), and were approved by the Animal Welfare Committee of the Generalitat de Catalunya (Project No. 10794) in conformity with relevant guidelines and regulations and the European Union legislation for the protection of experimental animals (86/609/EEC, 91/628/EEC, 92/65/EEC and 90/425/EEC).
Antigens and reagents
Mycobacterium bovis tuberculin (PPD-B, 2500 IU/ml) was obtained from CZ Vaccines (Porriño, Spain). The recombinant MTBC-specific antigens ESAT-6, CFP-10 and MPB83 were obtained from Lionex (Braunschweig, Germany) at a concentration of 500 μg/ml each. ESAT-6 and CFP-10 were mixed 1:1 in an antigenic cocktail (E/C). The antigenic complex P22 was produced by immunopurification of PPD-B (CZ Vaccines) as previously described41 and supplied by the Instituto de Investigación Carlos III (Madrid, Spain), at a concentration of 500 μg/ml.
Ex vivo IFN-γ release assay (IGRA)
Whole blood samples were collected at time points mentioned above from the jugular vein using heparinized tubes and subsequently stimulated in 96-well cell culture plates (Eppendorf, Hamburg, Germany) with PPD-B, P22 (except at week 7) and E/C at a final concentration of 20 μg/ml. Phosphate-buffered saline was used as an unstimulated control. Samples were incubated at 37 ºC and 5% CO2 for 18 ± 2 h. Plasma supernatants were collected after centrifugation at 18 g for 10 min and the released IFN-γ was measured by ELISA according to the ID.screen® Ruminant IFN-g kit (ID.vet, Grabels, France) instructions. ELISA plates were read as optical density obtained at 450 nm (OD450nm) using a spectrophotometer (Biotek Power Wave XS®, Agilent, dana Clara, USA). Antigen-specific IFN-γ responses were calculated as ΔOD450nm of antigen-stimulated well minus OD450nm of non-stimulated well (ΔOD450nm).
Multi-cytokine quantification assay
Cytokines in plasma supernatants from PPD-B and E/C stimulated and unstimulated whole blood samples were quantified at weeks 0, 5 and 9 post-challenge using a bovine customized multiplex assay kit (MILLIPLEX® Millipore, Merck Life Science S.L.U., Madrid, Spain) including a seven-plex panel for IL-1β, TNFα, IL-6, IL-10, IL-4, IFN-γ and IL-17A. 25 μl of each plasma sample and cytokine standards were analysed following the manufacturer’s instructions using xMAP® technology (Thermofisher Scientific, Waltham, MA, USA). ELISA plates were read on MAGPIX instrumental platform with xPONENT acquisition software (Thermofisher Scientific).
Flow cytometry
At week 0 (before challenge), peripheral blood mononuclear cells (PBMC) were isolated from blood samples and stimulated for 16 h (2 × 106 cells/well) with PPD-B (10 μg/ml) as previously described32. At week 0, 2 × 105 cells were stained with monoclonal antibodies (mAb) that recognise bovine IFN-γ (anti-bovine CC302 IgG1-Alexa Fluor® 647) from Bio-Rad Laboratories Inc. (Hercules, CA, USA), CD4 (anti-sheep 44.38 IgG2A-FITC), CD45RO (anti-bovine IL-A116 IgG3-RPE) and CD62L (anti-bovine CC32 IgG1-APC-Cy7) as previously described32. Stained cells were re-suspended in 200 µl PBS with 1% paraformaldehyde and analysed by flow cytometry in FacsARIA II (BD Diagnostics, Sparks, USA). Data were analyzed using FlowLogic TM from Inivai TM Technologies (Mentone, Victoria, Australia).
Antibody detection assays
Plasma samples from all experimental animals were analysed in duplicate to follow-up the antibody responses to MTBC after vaccination and challenge. Two indirect ELISAs were used to detect total IgG against the MPB83 antigen and the P22 antigenic complex, respectively. The two ELISAs were performed as previously described42,43. MPB83-IgG levels were calculated as OD450nm of antigen-coated well minus OD450nm of non-coated well (ΔOD450nm), whereas P22-IgG levels were calculated as ELISA percentage (E%) = [mean OD450nm of antigen-coated well/(2 × mean negative control OD450nm)] × 100.
Necropsy, pathological examination and computed tomography (CT)
Experimental animals were euthanized at 9 weeks post-challenge with an overdose of intravenous sodium pentobarbital (two goats from the control group were humanely euthanized at week 7). At necropsy, the diameter of TB compatible lesions in retropharyngeal (right and left), mediastinal (cranial and caudal) and tracheobronchial lymph nodes (LN) were measured, and the volume of lesions was inferred as previously described31. Other visible lesions in extrapulmonary tissues were also recorded and fixed in 10%-buffered formalin to be confirmed by histopathology and the Ziehl Neelsen stain to detect acid-fast bacilli. Lungs were also formalin-fixed, including airways perfusion with formalin before immersion, as previously described2, and then scanned by computed tomography (CT) using a 16-slice multi-detector scanner (Brivo CT-385, General Electric Healthcare, Madrid, Spain). CT analysis was performed as previously described31. Briefly, total volumes of lungs and TB lesions were measured using volume rendering images with different density patterns (i.e. solid, mineralized and cavitary lesions), and total volume of mineralization was calculated using 100–300 Hounsfield units.
Bacterial DNA quantification
After macroscopic pathologic evaluation, the whole mediastinal and tracheobronchial LNs were stored at − 20 °C until they were processed for bacteriology (one month later). Then LNs were thawed and homogenized in 10 ml of sterile distilled water using a homogenizer (Masticator, IUL Instruments, Barcelona, Spain). An aliquot of 1 ml of each homogenate was inactivated at 75 °C for 1 h and, in parallel, an aliquot of 100 ml of the M. caprae master seed (~ 108 CFU/ml), used for the challenge inoculum, was also inactivated and then ten-fold serially diluted to establish the standard curve. DNA samples were extracted using the ID Gene™ spin universal extraction kit (ID.vet) and amplified with the Mycobacterium tuberculosis complex Duplex kit (ID.vet). Amplification was performed in a 7500 fast real-time PCR system (Applied Biosystems, Walham, MA, USA). CFU genomic equivalents were calculated as previously described44.
Data analysis
A completely randomized design was carried out for studying the effects of vaccinations as a primary factor. Temperature and body weight were compared by using unidirectional ANOVA followed by Tukey test for multiple comparisons.
Antigen-specific immune responses (measured by IGRA, IgG-ELISA, Multi-cytokine assay and Flow Cytometry) were compared by using Kruskal–Wallis test with post hoc Dunn’s test. Volumes of lesions in LN and lungs (measured by direct visual inspection and CT, respectively), and mycobacterial DNA load (measured by qPCR) were compared by using Kruskal–Wallis test with post hoc one-tailed Dunn’s test.
Correlations of flow cytometry results (% of antigen-specific IFN-γ-producing T-memory cell subsets) with clinical and post-mortem parameters were assessed by using one-tailed non-parametric Spearman's Rank correlation coefficient. A p-value less than 0.05 was considered statistically significant.
GraphPad Prism version 8.0.0 (San Diego, CA, USA) was used for the statistical analysis.
Data availability
The databases generated and analyzed during the current study are available from the corresponding author on a reasonable request.
References
Gompo, T. R. et al. Risk factors of tuberculosis in human and its association with cattle TB in Nepal: A one health approach. One Health 10, 100156 (2020).
Pérez De Val, B. et al. Experimental model of tuberculosis in the domestic goat after endobronchial infection with Mycobacterium caprae. Clin. Vaccine Immunol. 18, 1872–1881 (2011).
Daniel, R. et al. Papers: Outbreak of tuberculosis caused by Mycobacterium bovis in golden Guernsey goats in great britain. Vet. Rec. 165, 335–342 (2009).
MAPA. Programa Nacional de Erradicacion de Tuberculosis Bovina 2022 (Infección por el complejo Mycobacterium tuberculosis). In Ministerio de Agricultura Pesca y Alimentación (MAPA). (2021).
Cvetnic, Z. et al. Mycobacterium caprae in cattle and humans in Croatia. Int. J. Tuberc. Lung Dis. 11(6), 652–658 (2007).
Seva, J. et al. Caprine tuberculosis eradication program: An immunohistochemical study. Small Rumin. Res. 46, 107–114 (2002).
Rodríguez, S. et al. Mycobacterium caprae infection in livestock and wildlife, Spain. Emerg. Infect. Dis. 17, 532–535 (2011).
Ábalos, P. et al. Vaccination of calves with the Mycobacterium bovis BCG strain induces protection against bovine tuberculosis in dairy herds under a natural transmission setting. Animals 12, 1083 (2022).
Arrieta-Villegas, C. et al. Long-term efficacy of BCG vaccination in goat herds with a high prevalence of tuberculosis. Sci. Rep. 10, 20369 (2020).
Marais, B. J. et al. BCG vaccination for bovine tuberculosis; conclusions from the Jerusalem One Health workshop. Transbound Emerg. Dis. 66, 1037–1043 (2019).
Srinivasan, S. et al. Prevalence of Bovine Tuberculosis in India: A systematic review and meta-analysis. Transbound Emerg. Dis. 65, 1627–1640 (2018).
Santos, N. et al. Quantification of the animal tuberculosis multi- host community offers insights for control. Pathogens 9, 421 (2020).
Bezos, J. et al. Evaluation of the Mycobacterium tuberculosis SO2 vaccine using a natural tuberculosis infection model in goats. Vet. J. 223, 60–67 (2017).
Roy, A. et al. Evaluation of the immunogenicity and efficacy of BCG and MTBVAC vaccines using a natural transmission model of tuberculosis. Vet. Res. 50, 82 (2019).
Vidal, E. et al. Field evaluation of the efficacy of Mycobacterium bovis BCG vaccine against tuberculosis in goats. BMC Vet. Res. 13, 252 (2017).
Palmer, M. V., Thacker, T. C. & Waters, W. R. Vaccination with mycobacterium bovis BCG strains Danish and Pasteur in white-tailed deer (Odocoileus virginianus) experimentally challenged with Mycobacterium bovis. Zoonoses Public Health 56, 243–251 (2009).
Buddle, B. M., Vordermeier, H. M., Chambers, M. A. & de Klerk-Lorist, L. M. Efficacy and safety of BCG vaccine for control of tuberculosis in domestic livestock and wildlife. Front. Vet. Sci. 5, 229–244 (2018).
Arrieta-Villegas, C. et al. Efficacy of parenteral vaccination against tuberculosis with heat-inactivated Mycobacterium bovis in experimentally challenged goats. PLoS ONE 13, e0196948 (2018).
Domingo, M. et al. Effectiveness and safety of a treatment regimen based on isoniazid plus vaccination with Mycobacterium tuberculosis cells’ fragments: Field-study with naturally mycobacterium caprae-infected goats. Scand. J. Immunol. 69, 500–507 (2009).
Roy, Á. et al. Response of goats to intramuscular vaccination with heat-killed Mycobacterium bovis and natural challenge. Comp. Immunol. Microbiol. Infect. Dis. 60, 28–34 (2018).
Juste, R. A. et al. Heterologous and homologous vaccine protection against Mycobacterium tuberculosis complex experimental infection in cattle and goats. Proceedings of the Seventh International Conference on Mycobacterium bovis 35 (2022).
Garrido, J. M. et al. Protection against tuberculosis in eurasian wild boar vaccinated with heat-inactivated Mycobacterium bovis. PLoS ONE 6, e24905 (2011).
Díez-Delgado, I. et al. Parenteral vaccination with heat-inactivated Mycobacterium bovis reduces the prevalence of tuberculosis-compatible lesions in farmed wild boar. Transbound Emerg. Dis. 64, e18–e21 (2017).
Thomas, J. et al. The response of red deer to oral administration of heat-inactivated Mycobacterium bovis and challenge with a field strain. Vet. Microbiol. 208, 195–202 (2017).
Balseiro, A. et al. Protective effect of oral BCG and inactivated Mycobacterium bovis vaccines in European Badgers (Meles meles) experimentally infected with M. bovis. Front. Vet. Sci. 7, 41 (2020).
Nol, P. et al. Effects of inactivated Mycobacterium bovis vaccination on molokai-origin wild pigs experimentally infected with virulent M. bovis. Pathogens 9, 199 (2020).
Beltrán-Beck, B. et al. Assessment of an oral Mycobacterium bovis BCG vaccine and an inactivated M. bovis preparation for wild boar in terms of adverse reactions, vaccine strain survival, and uptake by nontarget species. Clin. Vaccine Immunol. 21, 12–20 (2014).
Wangoo, A. et al. Advanced granulomatous lesions in Mycobacterium bovis-infected cattle are associated with increased expression of type I procollagen, γδ (WC1+) T cells and CD 68+ cells. J. Comp. Pathol. 133, 223–234 (2005).
Dean, G. et al. Comparison of the immunogenicity and protection against bovine tuberculosis following immunization by BCG-riming and boosting with adenovirus or protein based vaccines. Vaccine 32, 1304–1310 (2014).
Salguero, F. J. et al. Differential cell composition and cytokine expression within lymph node granulomas from BCG-vaccinated and non-vaccinated cattle experimentally infected with Mycobacterium bovis. Transbound Emerg. Dis. 64, 1734–1749 (2017).
Balseiro, A. et al. Assessment of BCG and inactivated Mycobacterium bovis vaccines in an experimental tuberculosis infection model in sheep. PLoS ONE 12, e0180546 (2017).
Arrieta-Villegas, C. et al. Immunogenicity and protection against mycobacterium caprae challenge in goats vaccinated with BCG and revaccinated after one year. Vaccines (Basel) 8, 1–16 (2020).
Smith, K. et al. Use of the MILLIPLEX® bovine cytokine/chemokine multiplex assay to identify Mycobacterium bovis-infection biomarkers in African buffaloes (Syncerus caffer). Vet. Immunol. Immunopathol. 231, 110152 (2021).
Pérez De Val, B. et al. Goats primed with Mycobacterium bovis BCG and boosted with a recombinant adenovirus expressing Ag85A show enhanced protection against tuberculosis. Clin. Vaccine Immunol. 19, 1339–1347 (2012).
Pérez De Val, B. et al. A multi-antigenic adenoviral-vectored vaccine improves BCG-induced protection of goats against pulmonary tuberculosis infection and prevents disease progression. PLoS ONE 8, e81317 (2013).
Sallusto, F., Lenig, D., Förster, R., Lipp, M. & Lanzavecchia, A. Two subsets of memory T lymphocytes with distinct homing potentials and effector functions. Nature 401, 708–712 (1999).
Vordermeier, H. M. et al. Viral booster vaccines improve Mycobacterium bovis BCG-induced protection against bovine tuberculosis. Infect. Immun. 77, 3364–3373 (2009).
Lindenstrøm, T., Knudsen, N. P. H., Agger, E. M. & Andersen, P. Control of chronic Mycobacterium tuberculosis infection by CD4 KLRG1–IL-2–secreting central memory cells. J. Immunol. 190, 6311–6319 (2013).
Arrieta-Villegas, C. et al. Evaluation of P22 antigenic complex for the immuno-diagnosis of tuberculosis in BCG vaccinated and unvaccinated goats. Front. Vet. Sci. 7, 374 (2020).
Vidal, E. et al. Transmission of tuberculosis caused by Mycobacterium caprae between dairy sheep and goats. Small Rumin. Res. 158, 22–25 (2018).
Infantes-Lorenzo, J. A. et al. Proteomic characterisation of bovine and avian purified protein derivatives and identification of specific antigens for serodiagnosis of bovine tuberculosis. Clin. Proteomics 14, 36 (2017).
Pérez de Val, B. et al. Serological follow-up of tuberculosis in a wild boar population in contact with infected cattle. Transbound Emerg. Dis. 64, 275–283 (2017).
Infantes-Lorenzo, J. A. et al. Specificity of serological test for detection of tuberculosis in cattle, goats, sheep and pigs under different epidemiological situations. BMC Vet. Res. 15, 70 (2019).
Vidal, E. et al. Experimental Mycobacterium microti infection in bank voles (Myodes glareolus). Microorganisms 10, 135 (2022).
Acknowledgements
The present work was financed through a grant of the Spanish Ministry of Science and Innovation (Ref. PID2019-105155RB-C32). IRTA is supported by CERCA Programme/Generalitat de Catalunya. Cristian Melgarejo is recipient of a pre-doctoral grant of the program “Don Carlos Antonio López” of the Republic of Paraguay (Ref. 88/2020). Instituto de Investigación Carlos III kindly supplied the P22 antigenic cocktail. We thank to Maite Martín, Zoraida Cervera, Abel Muñoz, Mónica Pérez, Rosa López, Anna Barceló and the staff of the BLS-3 Unit of IRTA-CReSA for their outstanding technical support.
Author information
Authors and Affiliations
Contributions
B.P. and E.V. conceived and planned the study. C.M., C.P., A.C., C.A.-V., X.M., Y.E., M.D., E.V. and B.P. performed the experiments and contributed to data collection. C.M., C.P., Y.E., E.V. and B.P. analysed and interpreted the data. B.P. and M.D. acquired funding and were in charge of project administration. I.S., J.B. and J.G. provided resources. C.M., E.V. and B.P. wrote the original draft. I.S., J.B., J.G. and M.D. contributed to writing, reviewing, and editing the final version of the manuscript.
Corresponding author
Ethics declarations
Competing interests
The authors declare no competing interests.
Additional information
Publisher's note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Melgarejo, C., Planas, C., Cobos, A. et al. A proof-of-concept study to investigate the efficacy of heat-inactivated autovaccines in Mycobacterium caprae experimentally challenged goats. Sci Rep 12, 22132 (2022). https://doi.org/10.1038/s41598-022-26683-0
Received:
Accepted:
Published:
DOI: https://doi.org/10.1038/s41598-022-26683-0
- Springer Nature Limited