Abstract
The drive towards a low carbon economy will lead to an increase in new lignocellulosic biorefinery activities. Integration of biorefinery waste products into established bioenergy technologies could lead to synergies for increased bioenergy production. In this study, we show that solid residue from the acid hydrolysis production of levulinic acid, has hydrochar properties and can be utilised as an Anaerobic Digestion (AD) supplement. The addition of 6 g/L solid residue to the AD of ammonia inhibited chicken manure improved methane yields by +14.1%. The co-digestion of biorefinery waste solids and manures could be a promising solution for improving biogas production from animal manures, sustainable waste management method and possible form of carbon sequestration.
You have full access to this open access chapter, Download conference paper PDF
Similar content being viewed by others
Keywords
1 Introduction
Lignocellulosic biomass is the most abundant renewable feedstock for biofuel production globally [1]. Biorefineries utilise a range of thermochemical processes to produce high platform chemicals for fuels and niche applications. Acid hydrolysis has received significant interest recent years for the valorisation of cellulose and hemi-cellulose fractions of biomass. Acid catalysts such as sulphuric acid (H2SO4) and hydrochloric acid (HCl) under aqueous conditions at mild temperatures (160–250 °C) can produce levulinic acid, lactic acid and 5-hydroxymethfural (5-HMF) [2]. Of which levulinic acid has been recognised as one of the most promising precursors for catalytic biofuel production. Several commercial pilot plants by GFBiochemicals (Caserta, Italy) and Segetis (USA) have demonstrated the potential technologies for the large scale deployment of catalytically produced biofuels [3].
The growth of biorefineries will create challenges to valorise all waste products. Acid catalysis of lignocellulose produces significant amounts of hydrochar-like Solid Residue (SR) material. Recent studies have utilised SR as a solid fuel, pyrolysis feedstock and building material among other applications [4]. Hydrochar has recently been investigated as Anaerobic Digestion (AD) supplement [5]. AD is a sustainable low-cost disposal process for organic matter as well as a source renewable energy in the form of biogas. Biogas is considered an important low-carbon bioenergy source however further implementation is limited due to feedstock constraints. Animal manure is among the most pressing environmental concerns and potential AD feedstock but is limited due to high inhibitor concentrations, most notably ammonium [6]. Recently, hydrochar has been shown to improve biogas yields from swine manure by 32–52% [7] by adsorbing ammonium, promoting microbial growth and buffering capacity during AD; but is limited due to the high costs associated with hydrochar production.
The pseudo-hydrochar properties of SR from acid catalysis could potentially be used as a low-cost hydrochar for anaerobic digestion supplementation, in order to improve the economics of both levulinic acid production and biogas. In this study, we investigated the feasibility of using SR from the sulphuric acid hydrolysis of Miscanthus x Giganteus to improve the anaerobic digestion of chicken manure.
2 Experimental
2.1 Solid Residue Preparation and Characterisation
Miscanthus x Giganteus was dried, ball-milled (<0.2 mm) and stored in air tight conditions for further use. Solid residue was prepared by heating 0.5 g of biomass in 10 ml of 2 M H2SO4 catalyst at 180 °C for 60 min under microwave heating. Post reaction the SR was separated, washed with deioinsed water and dried at 60 °C. The post aqueous reaction media was analysed using an HPLC as previously reported [8]. Levulinic acid and SR yields are reported on a dry mass basis and theoretical levulinic acid yield was calculated on structural sugar basis determined according to NREL standard 510-42618. The acid hydrolysis process yielded; 30.8 wt.% SR and 16.7 wt.% levulinic acid which corresponded to a theoretical 64.5% levulinic acid yield.
The total solids content and ash content were determined according to standards ASTM D4442 and NREL 42622 respectively. The CHNSO elemental combustion was carried using an Elemental Vario Macro Cube analyser, with oxygen % calculated by difference. The recalcitrance index, R50, for the SR was calculated according to Harvey et al. to estimate the carbon sequestration potential [9].
2.2 Batch Anaerobic Digestion
Chicken manure (CM) was collected from a local supplier, dried and stored in a desscitator until use. Inoculum sludge was collected from a local mesophilic AD plant operating at 31 °C. The total volatile solids of CM and inoculum was set at 8 wt.% with a C/N ratio of 7.1. The effect of SR on AD was investigated by varying the SR concentration by 2–10 g/L, compared with an un-supplemented control reactor. The biomethane potential assays were conducted in 500 ml glass flasks with working volume of 200 ml and purged with nitrogen gas for 5 min to achieve anaerobic conditions. The batch reactors were submerged in a water bath maintained at 31 ± 1 °C and the manually shaken once a day. The batch biomethane potential (BMP) assays were set up in duplicate and operated for 14 days with daily gas measurements. The primary biogas components, CH4 and CO2, were analysed utilising a GeoTech 2000 biogas analyser. The cumulative biogas volumes were then fitted to the modified Gompertz equation shown in Eq. 16.1 [6], using non-linear regression analysis in Matlab© (2016a).
3 Results
3.1 Material Characterisation
The properties of SR, Inoculum and CM are shown in Table 16.1. The SR carbon content exceeded 62%, with a high H/C and low O/C ratio indicating that the biomass underwent dehydration during the acid hydrolysis process, to produce SR with similar elemental properties to hydrochar. The acid hydrolysis process resulted in a high specific surface area (19 m2/g) which suggests the SR contains micro-porous structures suitable for adsorption. The pH of SR was measured in water at 1:10 mass ratio and the solid residue was slightly acidic and could negatively affect buffering capacity of AD. The recalcitrance index, R50, is a measurement of char stability to microbial degradation and suitability for carbon sequestration. The SR had a R50 of 0.66 which is comparable with that of biochar and indicates the land application of post-digestion SR could be a potential form of stable carbon sequestration.
3.2 Effects of SR on Methane Production During CM Digestion
Figure 16.1, shows the cumulative methane yields from the AD of CM over 14 days, alongside the predicted methane yields according to Eq. 16.1. The control reactor yielded 136 ml CH4/gVS compared with the CM stoichiometric CH4 potential of 286 ml/gVS, which corresponds with a biodegradability index of 48%. The addition of 2 gSR/L increased the methane yield (+12% CH4) with respect to the CM control, strongly indicating a beneficial effect to AD, by either promoting microbial growth or adsorbing inhibitors. There was only a minor improvement with increasing SR concentration at 6 g/L (+14.1% CH4) suggesting that the SR is not being degraded in the reactors. The minor improvement also indicates that the AD system is not undergoing significant stress and the positive effects of SR could potentially be more significant in more toxin-rich environments. There was a noticeable decrease in CH4 yields at higher SR loads (8 and 10 gSR/L), which can be attributed to the potential toxicity of SR on AD microorganisms. However, for all BMP conditions, SR addition resulted in higher methane yield than the CM control, which emphasises the positive effects on biogas production.
The Gompertz model has successfully been used to model BMP experiments from a range of substrates [6, 10]. For all experimental conditions in this study, the regression values exceeded 0.99, indicating a good fit of the model parameters shown in Table 16.2. The addition of SR increased the maximum methane production (Amax) by 6.9–11.8% and the maximum methane production rate (Rmax) by 18.3–25.9%, compared with the control reactor. This suggests that SR increased both the biodegradability of CM over 14 days and also the maximum microbial activity. The lag time of microbial AD system is associated with the maximum degradation rate and the adaption of the microbial community to the reaction conditions. Table 16.2, shows that SR concentrations prolonged the lag phase compared with the control reactor from 0.17 to 0.49 days. The increase in lag time implies a mild microbial inhibition with increasing SR concentrations and that the microbial community reacted negatively to those SR levels. This can be further seen with a decrease in Amax from 154.8 to 148.0 ml CH4/gVS day between 6 and 10 g/L suggesting that inhibition is caused from the SR itself and not from imbalances in the complex system. The negative effects of SR on AD must be further investigated, but does not negate the potential benefits.
4 Conclusion
In this study, the addition of SR from acid hydrolysis improved the methane yields, by 6.9–14.1%. During the mesophilic anaerobic digestion of CM. The SR from a high yielding levulinic acid process was determined to have hydrochar properties which were evident during the AD process. The modified Gompertz model suggested that SR increased both the microbial degradation rate and the cumulative methane yields, however toxicity was a factor at higher concentrations. The integration of AD into acid hydrolysis biorefineries could potentially create synergies for the dual production of biofuel and biogas.
References
S. Takkellapati, T. Li, M.A. Gonzalez, An overview of biorefinery-derived platform chemicals from a cellulose and hemicellulose biorefinery. Clean Technol. Environ. Policy 20(7), 1615–1630 (2018)
A. Mukherjee, M.J. Dumont, V. Raghavan, Review: sustainable production of hydroxymethylfurfural and levulinic acid: challenges and opportunities. Biomass Bioenerg. 72, 143–183 (2015)
F.D. Pileidis, M.M. Titirici, Levulinic acid biorefineries: new challenges for efficient utilization of biomass. ChemSusChem 9(6), 562–582 (2016)
S. Kang, J. Fu, G. Zhang, From lignocellulosic biomass to levulinic acid: a review on acid-catalyzed hydrolysis. Renew. Sustain. Energy Rev. 94, 340–362 (2018)
W. Guo, Y. Li, K. Zhao, Q. Xu, H. Jiang, H. Zhou (2019) Performance and microbial community analysis of anaerobic digestion of vinegar residue with adding of acetylene black or hydrochar. Waste and Biomass Valoriz., no. 0123456789
G.K. Kafle, L. Chen, Comparison on batch anaerobic digestion of five different livestock manures and prediction of biochemical methane potential (BMP) using different statistical models. Waste Manag. 48, 492–502 (2016)
H. Jin et al., Hydrochar derived from anaerobic solid digestates of swine manure and rice straw: a potential recyclable material. BioResources 13(1), 1019–1034 (2018)
G. Hurst, I. Brangheli, M. Peeters, S. Tedesco, Solid residue and by-product yields from acid-catalysed conversion of poplar wood to levulinic acid. Chem. Pap. 74(5), 1647–1661 (2020)
O.R. Harvey, L.J. Kuo, A.R. Zimmerman, P. Louchouarn, J.E. Amonette, B.E. Herbert, An index-based approach to assessing recalcitrance and soil carbon sequestration potential of engineered black carbons (biochars). Environ. Sci. Technol. 46(3), 1415–1421 (2012)
J. Pan, J. Ma, X. Liu, L. Zhai, X. Ouyang, H. Liu, Effects of different types of biochar on the anaerobic digestion of chicken manure. Bioresour. Technol. 275, 258–265 (2019)
Acknowledgements
This research was supported by Manchester Metropolitan University via the Research Accelerator Award (RAG 2017/18-113380). BBSRC NIBB’s network High Value from Plants funded the training and compositional analysis of biomass in conjunction with Celignis ltd. (CORE-TA–19).
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Open Access This chapter is licensed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license and indicate if changes were made.
The images or other third party material in this chapter are included in the chapter's Creative Commons license, unless indicated otherwise in a credit line to the material. If material is not included in the chapter's Creative Commons license and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder.
Copyright information
© 2021 The Author(s)
About this paper
Cite this paper
Hurst, G., Peeters, M., Tedesco, S. (2021). Integration of Catalytic Biofuel Production and Anaerobic Digestion for Biogas Production. In: Mporas, I., Kourtessis, P., Al-Habaibeh, A., Asthana, A., Vukovic, V., Senior, J. (eds) Energy and Sustainable Futures. Springer Proceedings in Energy. Springer, Cham. https://doi.org/10.1007/978-3-030-63916-7_16
Download citation
DOI: https://doi.org/10.1007/978-3-030-63916-7_16
Published:
Publisher Name: Springer, Cham
Print ISBN: 978-3-030-63915-0
Online ISBN: 978-3-030-63916-7
eBook Packages: EnergyEnergy (R0)