Abstract
Thermostable enzymes are a promising alternative for chemical catalysts currently used for the production of N-acetylglucosamine (GlcNAc) from chitin. In this study, a novel thermostable β-N-acetylglucosaminidase MthNAG was cloned and purified from the thermophilic fungus Myceliophthora thermophila C1. MthNAG is a protein with a molecular weight of 71 kDa as determined with MALDI-TOF-MS. MthNAG has the highest activity at 50 °C and pH 4.5. The enzyme shows high thermostability above the optimum temperature: at 55 °C (144 h, 75% activity), 60 °C (48 h, 85% activity; half-life 82 h), and 70 °C (24 h, 33% activity; half-life 18 h). MthNAG releases GlcNAc from chitin oligosaccharides (GlcNAc)2–5, p-nitrophenol derivatives of chitin oligosaccharides (GlcNAc)1–3-pNP, and the polymeric substrates swollen chitin and soluble chitosan. The highest activity was detected towards (GlcNAc)2. MthNAG released GlcNAc from the non-reducing end of the substrate. We found that MthNAG and Chitinase Chi1 from M. thermophila C1 synergistically degraded swollen chitin and released GlcNAc in concentration of approximately 130 times higher than when only MthNAG was used. Therefore, chitinase Chi1 and MthNAG have great potential in the industrial production of GlcNAc.
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Introduction
Large amounts of polysaccharides present in nature are an excellent source of valuable sugars, and chitin is one of them. Chitin is a vastly abundant polysaccharide and is used for the production of chitosan, chitin oligosaccharides, and GlcNAc (Kardas et al. 2012). Generally, chitin consists of linearly β-(1–4) linked N-acetylglucosamine molecules (GlcNAc). Chitosan, the deacetylated derivative of chitin, has wide application in many fields including medicine, pharmacology, environmental protection, and biobased packaging (Elieh-Ali-Komi and Hamblin 2016; Kardas et al. 2012; Van den Broek et al. 2015). Chitin oligosaccharides can be used as antimicrobial (No et al. 2002), antitumor, and anti-inflammatory agents (Azuma et al. 2015). GlcNAc has gained great attention as a candidate for multiple applications (Chen et al. 2010). In medicine, GlcNAc is considered as an inexpensive and non-toxic treatment for numerous diseases including osteoarthritis, inflammatory bowel disease, viral or bacterial infections, intestinal diseases, and cancer and for proliferation of skin cells during wound healing (Dalirfardouei et al. 2016; Salvatore et al. 2000; Xu et al. 2006; Xu et al. 2007a, b; Minami and Okamoto 2007). In cosmetics, GlcNAc is a valuable ingredient for improving skin quality (Riordan 1999; Bissett et al. 2007). In the food industry, GlcNAc is used as an additive in beer, milk, and wine (Xu et al. 2004a, b, c). Recently, GlcNAc was proposed as a biological C6 source for bioethanol production through fermentation. It was reported that fermentation with Mucor circinelloides NBRC6746 and Mucor ambiguous NBRC8092 yielded approximately 18.6 and 16.9 g/L ethanol from 50 g/L GlcNAc, respectively (Inokuma et al. 2013).
Chitin is used for industrial production of GlcNAc and is obtained mainly from exoskeletons of crustaceans and to a lesser extent from insects and fungal cell walls (Rinaudo 2006). Currently, degradation of chitin to GlcNAc from crustaceans is conducted with 15–36% HCl at 40–80 °C (Chen et al. 2010). Another production process involves the use of concentrated HCl at boiling temperature. Such harsh conditions lead to degradation of chitin and deacetylation of the monomer to glucosamine (GlcN). The produced GlcN is subsequently N-acetylated with acetic anhydride. However, there appears to be several problems in producing GlcNAc by chemical depolymerization of chitin, including high operational costs, low yield (below 65%), and acidic waste created by the use of HCl and acetic anhydride (Chen et al. 2010). A promising alternative for the chemical process is chitin depolymerization with enzymes. In comparison to the chemical process, enzymatic depolymerization is conducted under milder conditions and lower temperatures, and no hazardous wastes are released. In nature, chitin is degraded by three enzymes acting in concert: lytic polysaccharide monooxygenase (LPMO), chitinase, and β-N-acetylglucosaminidase (NAGase). LPMOs (EC 1.14.99.53) act in an oxidative way on the surface of crystalline chitin, where they introduce chain breaks and generate oxidized chain ends, thus promoting further degradation by chitinases (Vaaje-Kolstad et al. 2010). Chitinases (EC 3.2.1.14) catalyze the cleavage of the glycosidic bond in chitin chains and release chitin oligosaccharides and chitin dimers as end products. Products released by chitinase are finally converted to GlcNAc by NAGases (Ike et al. 2005; Hartl et al. 2012). According to the carbohydrate active enzymes classification (CAZy) (http://www.cazy.org/), LPMOs are classified to the auxiliary activity (AA) family AA10 and AA11, chitinases to glycoside hydrolase (GH) family 18, and NAGases to GH20 and GH3. Chitin-degrading enzymes are naturally produced by fungi, bacteria, plants, yeasts, insects, and even vertebrates, among various organisms (Bhattacharya et al. 2007; Keyhani and Roseman 1996). However, enzymes potentially appropriate for GlcNAc production from chitin at industrial scale are thermostable enzymes obtained from fungi (Østergaard and Sejr Olsen 2010). Fungal thermostable enzymes are currently used in industry, e.g., α-amylase in baking, because they tolerate high temperature, use shorter times to complete conversion, and have a long shelf life (Kristjansson 1989; Østergaard and Sejr Olsen 2010). Fungal thermophilic NAGases with a temperature optimum of 50–65 °C have been characterized from fungi, i.e., Aspergillus niger (Pera et al. 1997), Beauvaria bassiana (Bidochka et al. 1993), Lentinula edodes (Konno et al. 2012), Trichoderma harzianum (Ulhoa and Peberdy 1991; Lorito et al. 1994; Lisboa De Marco et al. 2004; Koga et al. 1991), and Penicillium oxalicum (Ryslava et al. 2011). However, after prolonged incubations at optimal or higher temperatures, their enzymatic activity diminished drastically or was lost. Therefore, there is a need for more robust thermophilic NAGases with improved thermostability. Recently, we have reported the production and the characterization of the thermostable chitinase Chi1, an endochitinase from the thermophilic filamentous fungus Myceliophthora thermophila C1 (Krolicka et al. 2018). In this study, we present the cloning and the properties of NAGase MthNAG, a second enzyme in the chitinolytic machinery of M. thermophila C1.
Materials and methods
Substrates and chemicals
Chitin from shrimp shells, Schiff’s reagent, 4-nitrophenyl-N-acetylglucosamine (GlcNAc-pNP), 4-nitrophenyl-N,N′-diacetyl-β-D-chitobiose ((GlcNAc)2-pNP) and 4-nitrophenyl-β-D-N,N′,N″-triacetylchitotriose ((GlcNAc)3-pNP), and 4-nitrophenyl-N-acetylgalactosamine (GalNAc-pNP) were obtained from Sigma-Aldrich (St. Louis, USA). GlcNac was obtained from Sigma-Aldrich (St. Louis, USA). Chitin oligosaccharides (GlcNAc)2–6 were obtained from Megazyme (Co. Wicklow, Ireland). Chitosan (90% deacetylation degree (% DDA), 100 kDa molecular weight) was purchased from Nippon Suisan Kaisha LTD. Swollen chitin was prepared according to Monreal and Reese (1969) with some modifications as described by Krolicka et al. (2018). Swollen chitin had a moisture content of 95.7%. All other chemicals were of the highest purity available. Chitinase Chi1 from M. thermophila C1 was isolated and purified as described by Krolicka et al. (2018).
Sequence analysis of MthNAG
The nucleotide sequence of the gene encoding for MthNAG (Mthnag) and deduced amino acid sequence of MthNAG were analyzed using Clone Manager software. BLAST analysis was performed at the NCBI server (https://blast.ncbi.nlm.nih.gov/Blast.cgi). Conserved domains were detected with Conserved Domain Search and Conserved Domain Database (Marchlerbauer et al. 2015) at the NCBI server (https://www.ncbi.nlm.nih.gov/Structure/cdd/wrpsb.cgi). The signal peptide was analyzed at the SignalP 4.0 server (http://www.cbs.dtu.dk/services/SignalP/), and the theoretical isoelectric point (pI) was calculated with the Compute pI/Mw tool on ExPASy server (https://web.expasy.org/compute_pi/). Potential N-linked and O-linked glycosylation sites were predicted by NetOGlyc 4.0 Server and NetNGlyc 1.0 Server (http://www.cbs.dtu.dk/services/). Prediction of the protein secondary structure and 3D was performed with the Phyre2 web portal (www.sbg.bio.ic.ac.uk/phyre2). 3D modeling was performed on the basis of the crystal structure of insect β-N-acetyl D-hexosaminidase of hex12 hexosaminidase (template ID: c3nsnA) which showed 90% coverage with the MthNAG sequence.
Fungal strain
The ascomycetous fungus Myceliophthora thermophila C1 is listed in the All-Russian Collection of Microorganisms of the Russian Academy of Sciences with accession number VKM F-3500D.
Gene cloning and protein production
The genome of M. thermophila C1 was screened for genes encoding for NAGases using a protein sequence of the fungal GH family 20 (XP_003656648) published at NCBI. This sequence was blasted against the M. thermophila C1 genome data base (Genencor International B.V., a DuPont company), and only one gene sequence of a putative GH20 NAGase was found in the M. thermophila C1 genome data base and this gene sequence has previously been published in a patent (Verdoes et al. 2010). The native gene encoding for a putative GH20 NAGase found in the genome of M. thermophila C1 was designated Mthnag. Mthnag was chosen for overexpression and characterization. The gene Mthnag was amplified from genomic M. thermophila C1 DNA with phusion DNA polymerase using the following designed primers (forward: GCTCGATTAAACATGTGGTCGCCG, reverse: GATGCGACCCGAATTCTCAAGCGACGA). The PCR program was as follows: 1× 98 °C for 30 s, 35× (1× 98 °C for 10 s, 35× 63.8 °C for 30 s, 72 °C for 30 s), 1× 72 °C for 10 min. The amplified gene was cloned into a C1 expression vector and homologously overexpressed in M. thermophila C1 according to the method described by Visser et al. (2011). In short, the expression cassette, containing the chi1 promoter, the gene Mthnag, and the terminator obtained from the expression vector, was transformed into a low-protease/(hemi-) cellulase-free M. thermophila C1-expression host. Ninety-six randomly integrated transformants were grown in a microtiter plate (Verdoes et al. 2007) and screened for NAGase activity in the culture broth using GlcNAc-pNP as substrate. The transformant showing the highest activity of MthNAG was selected for a 2-L fed-batch fermentation as previously reported (Visser et al. 2011). The strain was grown aerobically in mineral medium, with glucose as carbon source, ammonium sulfate as nitrogen source, and trace elements for essential salts (Verdoes et al. 2010). MthNAG was produced at pH 6.0 and 32 °C. The broth containing MthNAG was centrifuged at 20,000×g for 20 min, and the supernatant was filtered to remove cell biomass (filter 0.45 μm, Sartorius), concentrated fourfold (5 kDa PES membrane, Vivace 70, Sartorius), dialyzed against 10 mM potassium phosphate buffer pH 6.0, and freeze-dried to obtain a crude enzyme preparation.
Purification of MthNAG
The freeze-dried crude enzyme preparation (0.5 g) was dissolved in 50 mL 0.05 M Bis-Tris buffer pH 7.0 (buffer A) and purified by anion-exchange chromatography (IEX) and size exclusion chromatography (SEC) on an ÄKTA™ pure system. For IEX, the 50-mL sample was loaded onto a HiPrep DEAE FF 16/10 column (GE Healthcare Bio-Science AB, Uppsala, Sweden) and proteins were eluted with a gradient elution of 1 M NaCl in buffer A as follows: 0–20% for 10 column volumes (CV) and 20–45% for 10 CV with a flow rate of 5 mL min−1. Fractions were collected and screened for NAGase activity. The fraction with the highest NAGase activity was loaded onto a HiLoad 16/600 Superdex 75 pg SEC column (GE Healthcare Bio-Science AB, Uppsala, Sweden). Proteins were eluted isocratic with buffer A containing 0.15 M NaCl with a flow rate of 0.5 mL min−1. The absorbance was measured at 280 nm. Protein concentration was determined using the bicinchoninic acid assay (BCA) according to the instructions of the supplier (Pierce) with bovine serum albumin as standard. The evaluation of the purity and molecular weight of purified MthNAG was performed by matrix-assisted laser desorption time-of-flight mass spectrometry (MALDI-TOF-MS) as described by Krolicka et al. (2018).
Enzyme activity assays and kinetic parameters
For the standard enzyme assay, the enzyme solution (0.01 mL) was incubated with GlcNAc-pNP (2 mM) in 0.09 mL citrate-phosphate buffer (0.1 M, pH 4) at 50 °C in a microtiter plate. After 10 min incubation, 0.2 mL Tris/HCl buffer (0.25 M, pH 8.8) was added and the absorbance of released p-nitrophenol (pNP) was measured at 405 nm using a Tecan Safire plate reader (Grodig, Austria). One enzyme unit (U) was defined as the amount of enzyme required to release 1 μmol of pNP per minute. Activity on chitin oligosaccharide derivatives (pNP derivatives) was assayed with (GlcNAc)1–3-pNP at standard enzyme conditions. Activity for chitin and chitosan was assayed with 0.8 μM MthNAG incubated with 0.45% (w/v) swollen chitin or soluble chitosan in 0.96 mL Na-acetate buffer (0.05 M, pH 4.5) at 50 °C for 10 min. Reactions were terminated by heating at 96 °C for 10 min and subsequently centrifuged at 20,000×g for 5 min. The reducing sugars released from chitosan were analyzed with the p-hydroxybenzoic acid hydrazide (PAHBAH) assay (Lever 1973). For chitin, released GlcNAc was determined by high-performance anion-exchange chromatography (HPAEC). One U was defined as the amount of enzyme that liberated 1 μmol GlcNAc per minute from chitin or chitosan. The Km, Vmax, kcat, and Ki of MthNAG were determined for (GlcNAc)2 and GlcNAc-pNP. For GlcNAc-pNP, 2.1 nM MthNAG was incubated with GlcNAc-pNP in the range of 0.05–4 mM under standard enzyme assay conditions. For (GlcNAc)2, 2.1 nM MthNAG was incubated with (GlcNAc)2 in the range of 0.05–3.5 mM in citrate-phosphate buffer (0.1 M, pH 4.5) and released GlcNAc was determined by HPAEC. The kinetic parameters were calculated with GraphPad Prism software v.7.0 (GraphPad Software Inc., San Diego, CA). For all experiments, each reported value was the average of duplicate tests.
Biochemical characterization
The influence of pH on the activity of MthNAG was determined by incubating 2.1 nM MthNAG at different pH levels (3.0–7.0) in citrate-phosphate buffer (0.1 M) using the standard enzyme assay conditions. The influence of temperature on the activity of MthNAG was analyzed by incubating 2.1 nM MthNAG at the temperature range of 30–80 °C using the standard enzyme assay conditions. Thermostability was determined by pre-incubating 2.1 nM MthNAG at various temperatures (50–70 °C) in citrate-phosphate buffer (0.1 M, pH 4.5) for different time intervals, and the remaining enzyme activity was determined by performing the standard enzyme assay. For all experiments, each reported value was the average of duplicate tests.
Electrophoresis and identification of glycosylated proteins
Sodium dodecyl sulfate-polyacrylamide (10% (w/v)) gel electrophoresis (SDS-PAGE) was performed under reducing conditions using a NuPAGE Novex System (ThermoFisher Scientific, Bleiswijk, The Netherlands) with 10% (w/v) Bis-Tris gels. Gels were stained with SimplyBlue™ SafeStain according to the recommendation of the supplier (ThermoFisher Scientific). The isoelectric point of the enzyme was estimated by isoelectric focusing (IEF) using PhastGel™ IEF on a Pharmacia LKB Phast System (Pharmacia Biotech, Uppsala, Sweden) with a broad protein calibration kit (pH 3–10, GE Healthcare) as standard. Proteins were stained with Coomassie blue R-2. Glycosylation of proteins was detected by staining the SDS-PAGE gels with periodic acid-Schiff staining (PAS) (Zacharius et al. 1969).
Time course of hydrolysis of chitin oligosaccharides and pNP derivatives
To analyze the mode of action, the hydrolysis of chitin oligosaccharides (GlcNAc)2–5 and (GlcNac)2–3-pNP (0.18 mM) was performed with 2.1 nM MthNAG in 0.33 mL citrate-phosphate buffer (0.1 M, pH 4.5) at 50 °C. Time-point samples were taken, heated at 96 °C for 5 min, and centrifuged at 20,000×g for 5 min. Hydrolysis products were analyzed by HPAEC and each reported value was the average of duplicate tests. The quantification was based on calibration curves prepared for each chitin oligosaccharide.
Synergistic effect of MthNAG and Chitinase Chi1 on chitin hydrolysis
To study the synergistic effect of MthNAG and Chitinase Chi1, chitin hydrolysis was performed with 0.5% (w/v) swollen chitin in 1 mL citrate-phosphate buffer (0.1 M, pH 5.0) in two parallel runs: run I containing 0.8 μM MthNAG and run II containing 0.8 μM MthNAG and 1.2 μM Chitinase Chi1. Samples were incubated at 50 °C with agitation at 800 rpm. In time, samples were taken, heated at 96 °C for 10 min, and centrifuged at 20,000×g for 5 min. Hydrolysis products were analyzed by HPAEC, and each reported value was the average of the duplicate test. The quantification was based on the calibration curve for GlcNAc. GlcNAc production yields were calculated by comparing the amount of GlcNAc released to the maximal theoretical yield, which is equal to the initial substrate concentration considering that 1 mg of dry chitin could produce a maximum of 1.09 mg of GlcNAc.
HPAEC
HPAEC was performed on an ICS-3000 ion chromatography HPLC system equipped with a CarboPac PA-1 column (2 × 250 mm) in combination with a CarboPac PA-guard column (2 × 25 mm) at 22 °C and a pulsed electrochemical detector (PAD) in pulsed amperometric detection mode (Dionex) at 30 °C. The column was equilibrated with water. Sugars were eluted at a flow rate of 0.25 mL min−1. The gradient used was 0–25 min H2O, 25–65 min at 0–0.045 M NaOH, 65–70 min at 0.045 M NaOH–1 M sodium acetate in 0.1 M NaOH, 70–75 min at 1 M sodium acetate in 0.1 M NaOH, 75–75.1 min 1 M sodium acetate in 0.1 M NaOH–0.1 M NaOH, 75.1–80 min 0.1 M NaOH, and 80–95 min H2O. The PAD signal was increased by post column addition of 0.5 M NaOH at a flow rate of 0.15 mL min−1.
Results
Sequence analysis of MthNAG
The putative gene (Mthnag) encoding for NAGase MthNAG has an ORF of 2005 bp. The deduced 582-amino acid sequence of MthNAG was predicted to have a molecular weight of 62.6 kDa, a theoretical pI of 5.20, an N-terminal 21-amino acid signal peptide, three potential N-linked glycosylation sites, and two potential O-linked glycosylation sites. Multiple sequence alignment with other family GH20 hexosaminidases indicated that the protein sequence of MthNAG has the highest similarity to the GH family 20 protein from M. thermophila ATCC 42464 (accession: XP_003658680). The protein sequence of MthNAG shared 80% identity with the GH20 protein from Thielavia terrestris NRRL 8126 (accession: XP_003656648) and β-hexosaminidase 2 from Madurella mycetomatis (accession: KXX82839), and more than 60% identity was obtained for 79 GH20 proteins from fungal sources including Fusarium sp., Colletotrichum sp., Trichoderma sp., Scedosporium sp., and Neurospora sp. The protein sequence of MthNAG revealed three domains conserved in family GH-20 hexosaminidases: GH20_HexA_HexB-like domain (accession: cd06562), Glyco_hydro_20 domain (accession: pfam00728), and CHB_HEX domain (accession: PF03173) (Fig. 1 c), and a highly conserved pair of catalytic residues D–E preceded by a H-X-G-G motif (Fig. 1 a). The modeled secondary structure of MthNAG consists of 16 α-helixes and 21 β-sheets (Fig. 1 b), and the modeled tertiary structure has a (α/β)8 TIM-barrel structure with the active site lying at the center of the barrel convex side (Fig. 1 d).
Production and purification of MthNAG
The gene encoding for MthNAG (Mthnag) was amplified using the designed primers and cloned into the M. thermophila C1-expression host. The constructed M. thermophila C1 strain producing the highest activity of MthNAG was chosen for the production of the enzyme in a 2-L fermenter. Protein concentration in the culture broth was 3.5 g L−1, of which the overexpressed MthNAG represented 52% of the total protein. After removal of biomass, the crude enzyme preparation was freeze-dried and further subjected to a purification of MthNAG using IEX and SEC. MthNAG was purified to homogeneity as demonstrated by SDS-PAGE (Fig. 2 a) and MALDI-TOF-MS (Fig. 2 b). The specific activity of the purified MthNAG was 432 U mg−1.
Molecular weight, isoelectric point, and glycosylation of MthNAG
The molecular weight of MthNAG measured by SDS-PAGE was 62 kDa (Fig. 2 a) and that measured by MALDI-TOF-MS was 71.2 kDa (Fig. 2 b). In the MALDI-TOF-MS spectrum, the enzyme was identified as a monomeric protein at 71,188.9 [m/z] (single charged) and at 35,676.4 [m/z] (double charged). The measured isoelectric point of MthNAG was detected at pH 4.9 (Fig. 2 c). Staining of SDS-PAGE gel with PAS resulted in an intense magenta color of the MthNAG protein band (Fig. 2 d), showing that the enzyme is glycosylated.
Biochemical properties of MthNAG
The highest activity of MthNAG was detected at pH 4.5 and 50 °C (Fig. 3 a, b). The activity measurement showed bell-shaped profiles in the pH range of 3 to 8 and between 30 and 80 °C. MthNAG had a relatively high activity (> 40% of the maximum activity) in the range from 30 to 65 °C. At elevated temperatures, above the optimum, MthNAG performed with 30, 25, and 10% of relative activity at 70, 75, and 80 °C, respectively. MthNAG was notably thermostable at 55 °C (75% relative activity, at incubation time > 144 h), 60 °C (85% relative activity, after 48 h incubation; half-life 82 h), and 70 °C (33% relative activity, after 24 h incubation; half-life 18 h) (Fig. 3 c).
GlcNAc and GalNAc release from diverse substrates with MthNAG
The potential of MthNAG to release GlcNAc was examined for the natural chitin dimer (GlcNAc)2, chromogenic chitin oligosaccharide derivatives (GlcNAc)1–3-pNP, and polymeric substrates swollen chitin and soluble chitosan (Table 1 ). Specific activity for (GlcNAc)2 was expressed as the cleavage of two GlcNAc molecules and was 1077.8 ± 0.4 U mg−1. Among chitin oligosaccharide pNP derivatives, the enzyme showed the highest activity towards GlcNAc-pNP, which was about 200-fold higher than that towards (GlcNAc)2-pNP. Activity towards (GlcNAc)3-pNP was not detected. MthNAG was able to release GalNAc from GalNAc-pNP but with activity lower than that for GlcNAc-pNP. Next to oligomeric substrates, MthNAG was active towards polymeric chitin and chitosan. Activity towards chitin and chitosan was about 36,000-fold lower than that obtained for (GlcNAc)2. Kinetic parameters for MthNAG were determined for the natural substrate of the enzyme, (GlcNAc)2 and its mimic, GlcNAc-pNP. For (GlcNAc)2, the Vmax was 37.3 ± 5.4 μM min−1, Km was 0.25 ± 0.05 mM, and kcat was 293.7 ± 42.3 s−1. For GlcNAc-pNP, the Vmax was 1.76 ± 0.09 μM min−1, Km was 0.06 ± 0.01 mM, and kcat was 14.0 ± 0.7 s−1. However, kcat/Km for GlcNAc-pNP (231.6 s−1 mM−1) was lower than kcat/Km for (GlcNAc)2 (1174.8 s−1 mM−1). (GlcNAc)2 and GlcNAc-pNP inhibited the activity of MthNAG, and their inhibition effect was detected at substrate concentrations (Ki) of 0.50 ± 0.11 and 1.96 ± 0.26 mM, respectively.
Release of GlcNAc from chitin oligosaccharides and chitin oligosaccharide pNP derivatives with MthNAG
The release of GlcNAc from chitin oligosaccharides (GlcNAc)2–5 catalyzed by MthNAG was followed in time, and the reaction products were measured by HPAEC (Fig. 4 ). MthNAG efficiently degraded (GlcNAc)2 to two molecules of GlcNAc, and already after 30 min, the substrate was fully degraded (Fig. 4 a). All other oligosaccharides (GlcNAc)3–5 were shortened by one GlcNAc molecule in time, and the released intermediate products (GlcNAc)n − 1 were simultaneously degraded during the reaction. In the first 15 min, (GlcNAc)3 was degraded to molar equivalent concentration of GlcNAc and (GlcNAc)2 (Fig. 4 b), and the released (GlcNAc)2 dimers were degraded gradually hereafter. Hydrolysis of (GlcNAc)4 and (GlcNAc)5 resulted in the release of GlcNAc and the intermediate (GlcNAc)n − 1 oligosaccharides, which were further degraded (Fig. 4 c, d). The degradation rates in the first 5 min were as follows: 18.5 μM/min for (GlcNAc)2, 6.6 μM/min for (GlcNAc)3, 2.2 μM/min for (GlcNAc)4, and 1.7 μM/min for (GlcNAc)5. To determine the mode of action of MthNAG, the enzyme was incubated with (GlcNAc)2–3-pNP and the release of the products was followed in time. As shown in Fig. 5 , degradation of (GlcNAc)2–3-pNP progressed with the release of GlcNAc and intermediate (GlcNAc)n − 1-pNP, which were subsequently hydrolyzed by the enzyme. Similarly to chitin oligosaccharides, the enzyme showed preference towards shorter oligosaccharide substrate, since it degraded (GlcNAc)2-pNP two times faster than (GlcNAc)3-pNP (Fig. 5 a). GlcNAc was cleaved by the enzyme from the non-reducing end of the substrate (Fig. 5 b).
Effect of MthNAG and Chitinase Chi1 on the release of GlcNAc from swollen chitin
Chitinase Chi1 from M. thermophila C1 was previously shown to release mainly (GlcNAc)2 and traces of (GlcNAc)3 and GlcNAc from swollen chitin (Krolicka et al. 2018). In this work, Chitinase Chi1 and MthNAG were used to examine their synergistic effect on the release of GlcNAc from swollen chitin by performing two parallel runs and measuring the concentration of released GlcNAc in time. In run I, containing only MthNAG, the concentration of the released GlcNAc at the end of the reaction was 3.1 × 10−3 mM, while in run II, containing both enzymes, the concentration of GlcNAc was 0.39 mM at the end of incubation (Table 2 ). GlcNAc yield obtained with the mixture of both enzymes was equal to 37.8% which is about 13 times higher when only MthNAG was used (2.9%).
Discussion
The multiple sequence alignment of the protein sequence of MthNAG revealed the presence of conserved domains and catalytic residues typically found in GH20 family hexosaminidases. The GH20_HexA_HexB-like domain is a representative domain of the active site of GH20 hexosaminidases from microorganisms and higher organisms. The CHB_HEX superfamily domain was suggested to be a carbohydrate binding domain since it resembles the crystallographic structure of a cellulose binding domain in cellulase from Cellulomonas fimi (Xu et al. 1995; Tews et al. 1996). Putative features for protein maturation were found in MthNAG, including a 21-amino acid signal peptide and five glycosylation motifs. Tertiary structure predicted with 3D modeling revealed an (α/β)8 TIM-barrel conformation of MthNAG, which is typical for GH20 hexosaminidases. According to all these features, MthNAG can be classified to GH20 hexosaminidases.
The molecular weight of MthNAG measured with SDS-PAGE is in the range of molecular weights measured with SDS-PAGE for other fungal NAGases (Table 3 ). However, the molecular weight of MthNAG measured with MALDI-TOF-MS (71.2 kDa) was 8.6 kDa higher than the molecular weight calculated from the protein sequence (62.6 kDa). This difference is most likely due to the post-translational glycosylation of MthNAG performed by M. thermophila C1, as the purified MthNAG gave a strong magenta signal upon Schiff’s staining. Carbohydrates could potentially attach to the five glycosylation sites predicted in the MthNAG sequence. A similar increase in molecular weight of about 10 kDa caused by glycosylation was observed for NAGase from T. harzianum P1 (62.7 kDa) (Peterbauer et al. 1996). However, MthNAG and NAGase from T. harzianum P1 migrated differently in the SDS-PAGE. MthNAG appeared as a protein with lower molecular weight (62 kDa), while NAGase from T. harzianum P1 appeared as a protein with higher molecular weight (72 kDa). Anomalous behavior of glycoproteins has been described before, and the presence of carbohydrates attached to the protein (Segrest et al. 1971; Matagne et al. 1991) and the tertiary structure of the protein (Rath et al. 2009; Pitt-Rivers and Ambesi Impiombato 1968) were shown to influence this behavior. MALDI-TOF-MS is known to provide accurate molecular mass determination of proteins and glycoconjugates (Ledesma-Osuna et al. 2008; Yeboah and Yaylayan 2001).
MthNAG was found to have a pH optimum at pH 4.5 and a pI of 4.9, while the calculated pI from the amino acid sequence was 5.2. This difference between the theoretical pI predicted from the primary structure and the experimentally determined pI is common, and is in the error limits of the method (Kozlowski 2016).
MthNAG exhibits the highest catalytic activity at 50 °C, similar to other thermophilic fungal GH20 hexosaminidases (Table 3 ). Interestingly, MthNAG showed a notable thermostability above its optimal temperature, i.e., at 55, 60, and 70 °C, that to our knowledge has never been observed for other fungal NAGases. Literature reported fungal thermophilic NAGases with temperature optimum ≥ 50 °C which drastically lose their activities after prolonged incubation at optimal or higher temperatures. For example, NAGase 1 from B. bassiana has its temperature optimum at 57 °C but it lost 100% of activity after 60 min incubation at that temperature (Bidochka et al. 1993). NAGase from T. harzainum with an optimum at 50–60 °C lost 50% of its original activity within 1 h at 50 °C (Lisboa De Marco et al. 2004). At elevated temperatures, MthNAG was more stable than LeHex20A from L. edodes and NAGase from A. niger 419. At 60 °C, MthNAG retained 85% relative activity for 48 h, while LeHex20A from L. edodes was inactivated within 30 min (Konno et al. 2012). NAGase from A. niger 419, which was most active at 65 °C, lost 30% of activity after 15 min at 70 °C (Pera et al. 1997), while MthNAG lost 35% of activity after 5 h at that temperature. The notable thermostability of MthNAG is probably an evolutionary adaptation to preserve enzymatic function at elevated temperatures. This adaptation may include stabilizing interactions in folded protein, interactions between domains and presence of stable surface-exposed amino acids (Turner et al. 2007). Glycosylation of MthNAG may have also a positive effect on the thermostability, as glycosylation was shown to stabilize the enzyme conformation of glucoamylase from A. niger (Jafari-Aghdam et al. 2005) and improved the pH stability of NAGase PoHEX from Penicillium oxalicum (Ryslava et al. 2011).
MthNAG was very active towards the dimeric substrate (GlcNAc)2 and its mimic GlcNAc-pNP, which are typical substrates for N-acetylglucosaminidases. In addition, MthNAG showed N-acetylgalactosaminidase activity as it released the GalNAc moiety from GalNAc-pNP. The activity ratio of 1.25 between N-acetylglucosaminidase and N-acetylgalactosaminidase activities indicates that the enzyme has more or less the same activity towards GalNAc and GlcNAc conjugates. N-Acetylglucosaminidase and N-acetylgalactosaminidase activity are commonly found for members of the GH20 hexosaminidase family.
MthNAG showed activity for the trimeric chitin oligosaccharide derivative (GlcNAc)2-pNP, but no activity was detected towards the tetrameric (GlcNAc)3-pNP (Table 1 ). However, a time-course experiment with (GlcNAc)2–3-pNP revealed that GlcNAc was released from both substrates (Fig. 5 ) and that MthNAG released GlcNAc from the non-reducing end of the substrate. In the case of enzymes acting from the non-reducing end, the release of pNP from chitin oligosaccharide pNP derivatives depends on the length of the pNP derivative and the longer the pNP derivative, the more time the enzyme needs to reach the attached pNP and to release the dye. Therefore, it should be noted that the spectrophotometric activity measurement with pNP derivatives may give false results when the mode of action of the enzyme is not taken into account.
Studies of the kinetic parameters MthNAG indicated that (GlcNAc)2 is a good substrate for the enzyme, but the enzyme has a lower affinity for the natural substrate (higher Km) than for the synthetic mimic GlcNAc-pNP (lower Km). However, the higher catalytic efficiency (kcat and kcat/Km) towards (GlcNAc)2 indicates that (GlcNAc)2 is a more preferred substrate than GlcNAc-pNP. The Km for (GlcNAc)2 was comparable with the one from LeHex20A from L. edodes (Konno et al. 2012), although it was higher than the reported values for NAGase from T. harzianum (Ulhoa and Peberdy 1991) (Table 3 ). Although, MthNAG showed high enzymatic activity towards (GlcNAc)2 and GlcNAc-pNP, it was also inhibited by these substrates. The measured Ki for (GlcNAc)2 was equal to two times of Km, indicating that at Ki enzyme works at its Vmax. For setting a process, it is important to work below the Ki for (GlcNAc)2, which can be achieved by slowly adding the substrate. Substrate inhibition is also reported for other NAGases. For example, GlcNAc-pNP at a concentration of 0.4 mM inhibited fungal NAGase PoHEX from P. oxalicum (Ryslava et al. 2011). Blind docking experiment conducted on PoHEX revealed that substrate inhibition was a result of the presence of a “secondary” binding site. Whether such an additional binding site is a reason of substrate inhibition by MthNAG, additional blind docking experiment should be conducted for MthNAG.
Next to hydrolysis of (GlcNAc)2, MthNAG was capable of cleaving off GlcNAc moieties from chitin oligosaccharides (GlcNAc)3–5. The activity on chitin oligosaccharides has been reported for some other NAGasses (Table 3 ). The enzyme showed the highest preference towards (GlcNAc)2. In the first 5 min of incubation, (GlcNAc)2 was converted approximately three times faster than (GlcNAc)3 and almost 10 times faster than (GlcNAc)4 and (GlcNAc)5. MthNAG degraded chitin oligosaccharides (GlcNAc)3–5 non-processively in a consecutive reaction, which means that oligosaccharides were shortened by GlcNAc in time and their intermediate (GlcNAc)n − 1 were simultaneously degraded by the enzyme. In this way, the inhibition concentration of (GlcNAc)2 is not reached and the reaction can proceed to completion.
Fungal NAGases differ in their substrate diversity and activity towards GlcNAc-pNP (Table 3 ). They are in general known to degrade chitin dimers and oligosaccharides, but activity on polymeric chitin is not common for this group of enzymes. Activity towards chitin and chitosan makes MthNAG a unique enzyme among NAGases. Only a few bacterial NAGases and the fungal LeHex20A from L. edodes and M. anisopliae were reported to degrade chitin to some extent (Suginta et al. 2010; Konno et al. 2012; St. Leger et al. 1991). Activity on chitosan has not been reported before. Keeping in mind that MthNAG releases a single GlcNAc moiety from the non-reducing end, depolymerization of chitosan is only possible through the release of GlcNAc from the terminal site of chitosan chains. Furthermore, this result implies the acetylation profile of the chitosan used in the experiment (90% DDA), in which chitosan has numerous acetylated moieties at its non-reducing ends.
The activity on polymeric substrates may indicate that MthNAG could release GlcNAc moiety from glycopeptides, as it was reported for NAGase from A. niger (Bahl and Agrawal 1969).
However, the activity of MthNAG towards chitin and chitosan is relatively low and potential industrial production of GlcNAc from chitin cannot be based only on this enzyme. Therefore, chitin depolymerization was tested with addition of Chitinase Chi1, which was shown to release mainly (GlcNAc)2 from chitin (Krolicka et al. 2018). MthNAG and Chitinase Chi1 were expected to work in synergy, i.e., the (GlcNAc)2 released from chitin by Chitinase Chi1 will be hydrolyzed by MthNAG to GlcNAc. The amount of GlcNAc released by MthNAG and Chitinase Chi1 was compared with the amount released by MthNAG only. It was observed that when the enzymes worked together, they were able to release about 130 times more GlcNAc from swollen chitin than when only MthNAG was used. This result strongly indicates that these enzymes indeed work in synergy and can be used for the setup of an enzymatic production process of GlcNAc. The high thermostability of Chitinase Chi1 and MthNAG is an additional advantage for their potential industrial application.
In conclusion, a novel β-N-acetylglucosaminidase from the thermophilic fungus M. thermophila C1 was cloned and homologously overexpressed. The enzyme showed high specific activity towards (GlcNAc)2. MthNAG is notably thermostable, and to the best of our knowledge, MthNAG is the first reported fungal NAGase with such high thermostability. Together with Chitinase Chi1, MthNAG released about 130 times more GlcNAc from swollen chitin than when used alone. Application of both MthNAG and Chitinase Chi1 as a two-enzyme catalyst is a promising tool for production of GlcNAc from chitin. Furthermore, MthNAG can be used for determination of the deacetylation pattern of chitosan. In addition, due to the wide substrate specificity of MthNAG, this enzyme has potential to be used in combinations with other enzymes for deglycosylation of glycoconjugates such as glycans, glycoproteins, and glycolipids and for elucidation of their structure or changing their biological activity.
References
Azuma K, Osaki T, Minami S, Okamoto Y (2015) Anticancer and anti-inflammatory properties of chitin and chitosan oligosaccharides. J Funct Biomater 6(1):33–49. https://doi.org/10.3390/jfb6010033
Bahl OP, Agrawal KML (1969) Glycosidases of Aspergillus niger: I. Purification and characterization of α- and β-galactosidase and β-N-acetylglucosaminidase. J Biol Chem 244(10):2970–2978
Bhattacharya D, Nagpure A, Gupta RK (2007) Bacterial chitinases: properties and potential. Crit Rev Biotechnol 27:21–28. https://doi.org/10.1080/07388550601168223
Bidochka MJ, Tong KI, Khachatourians GG (1993) Partial purification and characterization of two extracellular N-acetyl-D-glucosaminidases produced by the entomopathogenic fungus Beauveria bassiana. Can J Microbiol 39:40–45
Bissett DL, Robinson LR, Raleigh PS, Miyamoto K, Hakozaki T, Li J, Kelm GR (2007) Reduction in the appearance of facial hyperpigmentation by topical N-acetylglucosamine. J Cosmet Dermatol 6:20–26
Cannon RD, Niimi K, Jenkinson HF, Shepherd MG (1994) Molecularcloning and expression of the Candida albicans β-N-acetylglucosaminidase (HEX1). Gene J Bacteriol 176:2640–2647
Chen J-K, Shen C-R, Liu C-L (2010) N-Acetylglucosamine: production and applications. Mar Drugs 8:2493–2516. https://doi.org/10.3390/md8092493
Dalirfardouei R, Karimi G, Jamialahmadi K (2016) Molecular mechanisms and biomedical applications of glucosamine as a potential multifunctional therapeutic agent. Life Sci 152:21–29. https://doi.org/10.1016/j.lfs.2016.03.028
Diez B, Rodriguez-Saiz M, de la Fuente JL, Moreno MA, Barredo JL (2005) The nagA gene of Penicillium chrysogenum encoding β-N-acetylglucosaminidase. FEMS Microbiol Lett 242:257–264. https://doi.org/10.1016/j.femsle.2004.11.017
Elieh-Ali-Komi D, Hamblin MR (2016) Chitin and chitosan: production and application of versatile biomedical nanomaterials. Int J Adv Res 4(3):411–427
Eriquez LA, Pisano MA (1979) Purification and characterization of an extracellular β-N-acetylhexosaminidase from Paecilomyces persicinus. J Bacteriol 137:620–626
Gkargkas K, Mamma D, Nedev G, Topakas E, Christakopoulos P, Kekos D, Macris BJ (2004) Studies on a N-acetyl-β-D-glucosaminidase produced by Fusarium oxysporum F3 grown in solid-state fermentation. Process Biochem 39:1599–1605. https://doi.org/10.1016/S0032-9592(03)00287-5
Hartl L, Zach S, Seidl-Seiboth V (2012) Fungal chitinases: diversity, mechanistic properties and biotechnological potential. Appl Microbiol Biotechnol 93(2):533–543. https://doi.org/10.1007/s00253-011-3723-3
Ike M, Nagamatsu K, Shioya A, Nogawa M, Ogasawara W, Okada H, Morikawa Y (2005) Purification, characterization, and gene cloning of 46 kDa chitinase (Chi46) from Trichoderma reesei PC-3-7 and its expression in Escherichia coli. Appl Microbiol Biotechnol 71(3):294–303. https://doi.org/10.1007/s00253-005-0171-y
Inokuma K, Takano M, Hoshino K (2013) Direct ethanol production from N-acetylglucosamine and chitin substrates by Mucor species. Biochem Eng J 72:24–32. https://doi.org/10.1016/j.bej.2012.12.009
Jafari-Aghdam J, Khajeh K, Ranjbar B, Nemat-Gorgani M (2005) Deglycosylation of glucoamylase from Aspergillus niger: effects on structure, activity and stability. Biochim Biophys Acta 1750:61–68. https://doi.org/10.1016/j.bbapap.2005.03.011
Jones CS, Kosman DJ (1980) Purification, properties, kinetics, and mechanism from β-N-acetylglucosamidase from Aspergillus niger. J Biol Chem 255:11861–11869
Kardas I, Struszczyk MH, Kucharska M, van den Broek LAM, van Dam JEG, Ciechańska D (2012) Chitin and chitosan as functional biopolymers for industrial applications. In: Navard P (ed) The European Polysaccharide Network of Excellence (EPNOE). Springer, Vienna, pp 329–373
Keyhani NO, Roseman S (1996) The chitin catabolic cascade in the marine bacterium Vibrio furnissii. Molecular cloning, isolation, and characterization of a periplasmic β-N-acetylglucosaminidase. J Biol Chem 271(27):33425–33432
Kim S, Matsua I, Ajiksaka NH, Kitamoto K (2002) Cloning and characterization of the gene nagA that encodes β-N-acetylglucosaminidase from Aspergillus nidulans and its expression in Aspergillus oryzae. Biosci Biotechnol Biochem 66(10):2168–2175 https://doi.org/10.1271/bbb.66.2168
Koga K, Iwamoto Y, Sakamoto H, Hatano K, Sano M, Kato I (1991) Purification and characterization of β-N-acetylhexosaminidase from Trichoderma harzianum. Agric Biol Chem 55(11):2817–2823
Konno N, Takahashi H, Nakajima M, Takeda T, Sakamoto Y (2012) Characterization of β-N-acetylhexosaminidase (LeHex20A), a member of glycoside hydrolase family 20, from Lentinula edodes (shiitake mushroom). AMB Express 2:29. https://doi.org/10.1186/2191-0855-2-29
Kozlowski LP (2016) IPC—isoelectric point calculator. Biol Direct 11:55. https://doi.org/10.1186/s13062-016-0159-9
Kristjansson JK (1989) Thermophilic organisms as sources of thermostable enzymes. Trends Biotechnol 7:349–353
Krolicka M, Hinz SW, Koetsier M, Joosten R, Eggink G, van den Broek LA, Boeriu CG (2018) Chitinase Chi1 from Myceliophthora thermophila C1, a thermostable enzyme for chitin and chitosan depolymerization. J Agric Food Chem 66(7):1658–1669. https://doi.org/10.1021/acs.jafc.7b04032
Ledesma-Osuna AI, Ramos-Clamont G, Vázquez-Moreno L (2008) Characterization of bovine serum albumin glycated with glucose, galactose and lactose. Acta Biochim Pol 55(3):491–497
Lever M (1973) Colorimetric and fluorometric carbohydrate determination with p-hydroxybenzoic acid hydrazide. Biochem Med 7:274–281. https://doi.org/10.1016/0006-2944(73)90083-5
Li HM, Crouch JA, Belanger FC (2005) Fungal endophyte N-acetylglucosaminidase expression in the infected host grass. Mycol Res 109(3):363–373
Lisboa De Marco J, Valadares-Inglis MC, Felix CR (2004) Purification and characterization of an N-acetylglucosaminidase produced by a Trichoderma harzianum strain which controls Crinipellis perniciosa. Appl Microbiol Biotechnol 64(1):70–75. https://doi.org/10.1007/s00253-003-1490-5
Lorito M, Hayes CK, Di Pietro A, Woo SL, Harman GE (1994) Purification, characterization, and synergistic activity of a glucan 1,3-β-glucosidase and an N-acetyl- β –glucosaminidase from Trichoderma harzianum. Mol Plant Pathol 84(4):398–405. https://doi.org/10.1094/Phyto-84-398
Marchlerbauer A, Derbyshire MK, Gonzales NR, Lu S, Chitsaz F, Geer LY, Geer RC, He J, Gwadz M, Hurwitz DI (2015) CDD: NCBI’s conserved domain database. Nucleic Acids Res 43:222–226. https://doi.org/10.1093/nar/gku1221
Matagne A, Joris B, Frere J-M (1991) Anomalous behaviour of a protein during SDS/PAGE corrected by chemical modification of carboxylic groups. Biochem J 280(2):553–556
Matsuo I, Kim S, Yamamoto Y, Ajisaka K, Maruyama J, Nakajima H, Kitamoto K (2003) Cloning and overexpression of β-N-acetylglucosaminidase encoding gene nagA from Aspergillus oryzae and enzyme-catalyzed synthesis of human milk oligosaccharide. Biosci Biotechnol Biochem 67(3):646–650. https://doi.org/10.1271/bbb.67.646
Mega T, Ikenaka T, Matsushima Y (1970) Studies on N-acetyl-β-D-glucosaminidase of Aspergillus oryzae I: 1. Purification and characterization of N-acetyl-β-D-glucosaminidase obtained from takadiastase. J Biochem 68:109–117
Minami S, Okamoto Y (2007) Drug for remedy or treatment of wound. WO patent NO. 2005112948A1
Monreal J, Reese ET (1969) The chitinase of Serratia marcescens. Can J Microbiol 15(7):689–696. https://doi.org/10.1139/m69-122
No HK, Young Park N, Ho Lee S, Meyers SP (2002) Antibacterial activity of chitosans and chitosan oligomers with different molecular weights. Int J Food Microbiol 74(1–2):65–72. https://doi.org/10.1016/S0168-1605(01)00717-6
Ohtakara A, Yoshida M, Murakami M, Izumi T (1981) Purification and characterization of β-N-acetylhexosaminidase from Pycnoporus cinnabarinus. Agric Biol Chem 45(1):239–247
Østergaard LH, Sejr Olsen H (2010) Industrial applications of fungal enzymes. In: Hofrichter M (ed) 2nd edn. Springer-Verlag, Berlin Heidelberg, pp 269–290
Pera LM, Infante Majolli MV, Baigori MD (1997) Purification and characterization of a thermostable and highly specific β-N-acetyl-D-glucosaminidase from Aspergillus niger 419. Biotechnol Appl Biochem 26(3):183–187
Peterbauer CK, Lorito M, Hayes CK, Harman GE, Kubicek CP (1996) Molecular cloning and expression of the nag1 gene (N-acetyl-β-D-glucosaminidase-encoding gene) from Trichoderma harzianum P1. Curr Genet 30(4):325–331
Pitt-Rivers R, Ambesi Impiombato FS (1968) The binding of sodium dodecyl sulphate to various proteins. Biochem J 109:825–830
Rath A, Glibowicka M, Nadeau VG, Chen G, Deber CM (2009) Detergent binding explains anomalous SDS-PAGE migration of membrane proteins. PNAS 106(6):1760–1765. https://doi.org/10.1073/pnas.0813167106
Reyes F, Calatayud J, Vazquez C, Jesfis Martinez M (1989) β-N-Acetylglucosaminidase from Aspergillus nidulans which degrades chitin oligomers during autolysis. FEMS Microbiol Lett 53(1–2):83–87
Rinaudo M (2006) Chitin and chitosan: properties and applications. Prog Polym Sci 31:603–632. https://doi.org/10.1016/j.progpolymsci.2006.06.001
Riordan NH (1999) Skin treatment system. US Patent NO 005866142A
Ryslava H, Kalendova A, Doubnerova V, Skocdopol P, Kumar V, Kukacka Z, Pompach P, Vanek O, Slamova K, Bojarova P, Kulik N, Ettrich R, Kren V, Bezouska K (2011) Enzymatic characterization and molecular modeling of an evolutionarily interesting fungal β-N-acetylhexosaminidase. FEBS J 278(14):2469–2484. https://doi.org/10.1111/j.1742-4658.2011.08173.x
Salvatore S, Heuschkel R, Tomlin S, Daviesà SE, Edwards S, Walker-Smith JA, French I, Murch SH (2000) A pilot study of N-acetylglucosamine, a nutritional substrate for glycosaminoglycan synthesis, in paediatric chronic inflammatory bowel disease. Aliment Pharmacol Ther 14(12):1567–1579
Segrest JP, Jackson RL, Andrews EP, Marchesi VT (1971) Human erythrocyte membrane glycoprotein: a re-evaluation of the molecular weight as determined by SDS polyacrylamide gel electrophoresis. Biochem Biophys Res Commun 44(2):390–395
St. Leger RJ, Cooper RM, Charnley AK (1991) Characterization of chitinase and chitobiase produced by the entomopathogenic fungus Metarhizium anisopliae. J Invertebr Pathol 58(3):415–426. https://doi.org/10.1016/0022-2011(91)90188-V
Suginta W, Chuenark D, Mizuhara M, Fukamizo T (2010) Novel β-N-acetylglucosaminidases from Vibrio harveyi 650: cloning, expression, enzymatic properties, and subsite identification. BMC Biochem 11:40. https://doi.org/10.1186/1471-2091-11-40
Sullivan PA, Mchugh NJ, Romana LK, Shepherd MG (1984) The secretion of N-acetylglucosaminidase during germ-tube formation in Candida albicans. J Gen Microbiol 130(9):13–22. https://doi.org/10.1099/00221287-130-9-2213
Tews I, Perrakis A, Oppenheim A, Dauter Z, Wilson KS, Vorgias CE (1996) Bacterial chitobiase structure provides insight into catalytic mechanism and the basis of Tay-Sachs disease. Nat Struct Biol 3(7):638–648
Turner P, Mamo G, Nordberg Karlsson E (2007) Potential and utilization of thermophiles and thermostable enzymes in biorefining. Microb Cell Factories 6:9. https://doi.org/10.1186/1475-2859-6-9
Ulhoa CJ, Peberdy JF (1991) Purification and characterization of an extracellular chitobiase from Trichoderma harzianum. Curr Microbiol 23(5):285–289
Vaaje-Kolstad G, Westereng B, Horn SJ, Liu ZL, Zhai H, Sørlie M, Eijsink VGH (2010) An oxidative enzyme boosting the enzymatic conversion of recalcitrant polysaccharides. Science 330:219–222. https://doi.org/10.1126/science.1192231
Van den Broek LAM, Knoop RJI, Kappen FHJ, Boeriu CG (2015) Chitosan films and blends for packaging material. Carbohydr Polym 116:237–242 https://doi.org/10.1016/j.carbpol.2014.07.039
Verdoes JC, Punt PJ, Burlingame R, Bartels J, van Dijk R, Slump E, Meens M, Joosten R, Emalfarb M (2007) A dedicated vector for efficient library construction and high throughput screening in the hyphal fungus Chrysosporium lucknowense. Ind Biotechnol 3(1):48–57. https://doi.org/10.1089/ind.2007.3.048
Verdoes JC, Punt PJ, Burlingame RP, Pynnonen CM, Olson PT, Wery J, Visser JH, Emalfarb MAVJ (2010) New fungal production system. Int. Patent WO/2010/107303
Visser H, Joosten V, Punt PJ, Gusakov A, Olson PT, Joosten R, Bartels J, Visser J, Sinitsyn A, Emalfarb M, Verdoes J, Wery J (2011) Development of a mature fungal technology and production platform for industrial enzymes based on a Myceliophthora thermophila isolate, previously known as Chrysosporium lucknowense C1. Ind Biotechnol 7(3):214–223. https://doi.org/10.1089/ind.2011.7.214
Xu G-Y, Ong E, Gilkes NR, Kilburn DG, Muhandiram DR, Harris-Brandts M, Carver JP, Kay LE, Harvey TS (1995) Solution structure of a cellulose-binding domain from Cellulomonas fimi by nuclear magnetic resonance spectroscopy. Biochemistry 34(21):6993–7009
Xu Q, Liu J, Yuan Z (2004a) The use of N-acetyl-D-glucosamine as additive in beer and beer comprising N-acetyl-D-glucosamine. WO Patent NO. 2004085603A1
Xu Q, Liu J, Yuan Z (2004b) The use of N-acetyl-D-glucosamine as additive in milk products. WO Patent NO. 2004093556A1
Xu Q, Liu J, Yuan Z (2004c) The use of N-acetyl-D-glucosamine as additive in wine and wine comprising N-acetyl-D-glucosamine. WO Patent NO. 2004085604A1
Xu Q, Liu J, Yuan Z (2006) Use of N-acetyl-D-glucosamine in preparation of drugs for the treatment of cacer and metastasis. EP Patent NO. 1666046A1
Xu Q, Liu J, Yuan Z (2007a) Use of N-acetyl-D-glucosamine in treatment of local lesions and systematic symptoms related to infections of virus or bacteria. US Patent NO. 20070042995A1
Xu Q, Liu J, Yuan Z (2007b) Compound antibacterial drugs comprising N-acetyl-D-glucosamine. US Patent NO. 20070191291A1
Yamamoto K, Lee KM, Kumagai H (1985) Purification and characterization of β-N-acetylhexosaminidase from Penicillium oxalicum. Agric Biol Chem 49(3):611–619. https://doi.org/10.1271/bbb1961.49.611
Yeboah FK, Yaylayan VA (2001) Analysis of glycated proteins by mass spectrometric techniques: qualitative and quantitative aspects. Nahrung/Food 45(3):164–171. https://doi.org/10.1002/1521-3803(20010601)45:3<164::AID-FOOD164>3.0.CO;2-Q
Zacharius RM, Zell TE, Morrison JH, Woodlock JJ (1969) Glycoprotein staining following electrophoresis on acrylamide gels. Anal Biochem 30(1):148–152
Zhuravleva NV, Lukyanov PA, Pivkin MV (2004) N-acetyl-β-D-hexosaminidase secreted by the marine fungus Phoma glomerata. Appl Biochem Microbiol 40(5):448–453
Acknowledgments
The authors acknowledge the technical support by Sykur Sykur. This research received funding from the Netherlands Organisation for Scientific Research (NWO) in the framework of the TASC Technology Area BIOMASS.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no conflict of interest.
Ethical approval
This article does not contain any studies with human participants or animals performed by any of the authors.
Rights and permissions
Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made.
About this article
Cite this article
Krolicka, M., Hinz, S.W.A., Koetsier, M.J. et al. β-N-Acetylglucosaminidase MthNAG from Myceliophthora thermophila C1, a thermostable enzyme for production of N-acetylglucosamine from chitin. Appl Microbiol Biotechnol 102, 7441–7454 (2018). https://doi.org/10.1007/s00253-018-9166-3
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00253-018-9166-3