Abstract
Purpose
A lots of poultry litter (PL) is being generated every day from poultry industries and improper management leads to different environmental problems. Production of biochar from PL is a new management strategy of PL which is a nutrient-rich organic amendment for improving soil nutritional status. The experiment was aimed for the production of poultry litter biochar (PLB) from fresh PL to assess the important properties of both PL and PLB, and to observe the effects on plant growth. It also appraised the change of soil properties after PL and PLB application.
Methods
Poultry litter biochar was produced from fresh PL heated at 300 °C temperature for 10 min in muffle furnace. Poultry litter was applied into the soil at 2.5, 5.0, 7.5 and 10 t ha−1 and PLB was applied at 1, 2, 3 and 4 t ha−1 along with control. Gima kalmi (Ipomoea aquatica) was grown as test plant. To assess the potentiality and residual effect, the same plant was grown consecutively after harvesting first crop. Post-harvest soil analysis was also carried out after harvesting the first crop.
Results
After pyrolysis pH, EC, organic carbon, available nitrogen, phosphorus, potassium, calcium, total phosphorus, potassium, calcium, magnesium, and iron were increased in PLB. A significant (p < 0.001) increase in plant growth and biomass production was observed and it was higher in PLB-treated soil than that of the PL-treated soil for both first and second crop.
Conclusion
Poultry litter biochar might be a promising organic fertilizer with high nutrient composition than fresh PL. This also could be an ecofriendly management strategy for sustainable agriculture and long-term productivity.
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
Introduction
Long-term sustainability of agriculture and attaining future food requirement have become burning issues and can be considered as a great challenge of the twenty-first century (Gruhn et al. 2000; Scholz et al. 2014). To fulfill the future food demand, the reckless application of inorganic fertilizer has steadily increased for intensive agriculture. Eventually, it leads to decline in the soil’s physical, chemical and biological health (soil degradation, nutrient imbalance, soil acidity, etc.) resulting in poor crop yields (Widowati et al. 2012; Usman et al. 2015; Oshunsanya and Aliku 2016), whereas the use of organic fertilizer improves soil properties and plays an important role in long-term soil conservation by maintaining or restoring its fertility which ensures the sustainable agricultural production and also enhances the crop quality (Islami et al. 2011; Widowati et al. 2012; Adhami et al. 2014; Ali et al. 2017; Joardar and Rahman 2018). But rapid decomposition and mineralization result from using organic materials which leads to repeatedly high application doses and subsequently contributes to increasing global warming through carbon emission (Jenkinson et al. 1991; Lehmann et al. 2006, 2009; Sohi et al. 2009). Realizing the problem and to introduce a climate-smart agriculture, scientists are trying to use recalcitrant organic materials, such as ‘biochar’, a more resistant or stable carbon-rich organic material as a tool for improving soil fertility and productivity while also fighting the global challenge of climate change (Lehmann et al. 2006; Lehmann and Joseph 2009; Islami et al. 2011; Widowati et al. 2012; Scholz et al. 2014).
Global interest in the use of biochar in agriculture as an organic fertilizer, to improve the soil condition, has just inaugurated in the past few years (Verheijen et al. 2010; Bruun 2011; Nair et al. 2017). The application of biochar to agricultural soil is rapidly emerging day by day as a new management strategy as it gives greater resistance to microbial decay than other soil organic matter (SOM) and consequently provides nutrients for long time because of its stability with specific chemical structure (Baldock and Smernik 2002; Steiner et al. 2007; Cheng et al. 2008) and, therefore, indirectly contribute to enhance plant growth (Lehmann et al. 2003a; Steiner et al. 2007; Chan et al. 2008). Applying biochar into soil also helps in carbon (C) sequestration by stabilizing SOM which can contribute to reduction of greenhouse gas emission from soil (Lehmann et al. 2006; Steiner et al. 2007; Chan et al. 2007a; Lehmann and Joseph 2009; Nair et al. 2017). Though the decomposition rate of biochar is slow than the uncharred organic material but it is not strictly inert material, it takes a long time to decompose (Thies and Rillig 2009). Biochar can be originated from a diverse range of biomass materials including animal manures, agricultural wastes, rice husks, leaves, wood residues, weeds, etc. (Lehmann and Joseph 2009; Scholz et al. 2014) by thermal decomposition (pyrolysis) under no or limited supply of oxygen at relatively low to moderate temperatures (< 700 °C). The quality and nutrient status of biochar from feedstocks of animal origin such as poultry litter, cow manure, and sewage sludge are higher than biochar made from plants or crop residues (Shinogi 2004; Chan et al. 2007a, b, 2008; Gaskin et al. 2008; Covell et al. 2011).
Poultry litter itself is a valuable source of organic fertilizer for plant nutrients as it contains high content of essential macro and micronutrients (Warman 1986; Dikinya and Mufwanzala 2010). But improper management and over application of PL are responsible for ammonia volatilization, higher nitrogen mineralization, nutrients leaching, surface water contamination by excessive phosphorus and also damage of sensitive crops, etc. (Schilke-Gartley and Sims 1993; Chan et al. 2007c; Reddy et al. 2008; AWMFH 2013). Different environmental pollutions (emission of greenhouse gases, offensive odor, etc.) are also results from faulty droppings or mismanagement of PL (O’Neill and Phillips 1992; Abdullah-Al-Amin et al. 2009; Akanni and Benson 2014). Though there are different strategies to manage PL, the conversion of PL into PLB now can be considered as the most reliable, safe and effective strategy because of its stability and unique beneficial characteristics that will help to handle both soil and environmental pollution issues and will be an environment friendly management strategy of utilizing this organic resource in agriculture (Lehmann 2009; Lehmann and Joseph 2009; Draper and Tomlinson 2012; Scholz et al. 2014).
Poultry industry is located throughout the world and this sector has been growing at more than 5% per annum (FAO 2006). In Bangladesh, this rate is around 20% within the last two decades (Islam et al. 2014). The global production of poultry was estimated almost 22 billion in 2010 which is nearly three times more than that of in 1980 (MacLeod et al. 2013). A huge amount of PL is generated every day. On a dry weight basis, about 0.7 to 2.0 tons of litter per 1000 chickens per year have been reported (Bolan et al. 2010). In case of one chicken, approximately 8 to 11 lb of fresh manure is produced monthly (Foreman and Long 2013).
Most of the soils of Bangladesh contain less than 1.5% SOM and few soils contain even less than 1% SOM (FRG 2012). Moreover, the rate of SOM decomposition and mineralization in Bangladesh soils is usually very high because of temperate regime which is a basic problem in stability of SOM (Karim and Iqbal 2001). So, production of stable biochar from organic wastes and its use in soil can play a vital role to solve the current problem in agriculture and also can contribute to mitigate the raising greenhouse gas emission (Lehmann et al. 2006, 2009; Lehmann 2009; Sarkar et al. 2015).
Though PL itself has been used as organic fertilizer, there is limited research work for the production of PLB and its contribution in maintaining soil nutrients and effects on plant growth. The present research work was conducted for PL management by producing PLB from fresh PL, to determine the most important properties of both PL and PLB, to see the growth of gima kalmi under the application of PL and PLB in soil and also to evaluate the changes of soil properties after PL and PLB application.
Materials and methods
Study site
Pot experiment was carried out in the net house of Soil, Water and Environment Discipline, Khulna University, Bangladesh and all the analyses were performed in the laboratory of the Discipline.
Sample collection and preparation
Soil sample was collected from the surface of agricultural field behind the Khulna University campus (N22°45.122′/E89°31.456′). Collected soil sample was air dried, and visible roots and other debris were removed. The larger soil aggregates were broken gently using a wooden hammer, sieved through a 2.0-mm sieve and mixed thoroughly to prepare a composite soil sample (USDA 1951). The sieved soil was used for plant growth. A portion of the soil sample was further passed through 0.5-mm sieve for laboratory analyses.
Poultry litter was collected from a local poultry farm situated nearby the Khulna city. At the time of collection of bedding materials, feather, etc. were avoided as much as possible. Collected PL was sun dried for 3 days to remove extra moisture. Then, the dried PL was broken gently by a wooden hammer and sieved using a 0.5-mm sieve. The sieved PL was then preserved in plastic pot for further use.
Biochar production from poultry litter
Poultry litter biochar was produced through pyrolysis process using muffle furnace under limited oxygen condition (Baldock and Smernik 2002; Abbasi and Anwar 2015; Vijayanand et al. 2016). The pre-processed PL was taken into porcelain cup and kept into muffle furnace at 300 °C temperature for 10 min. So, in this experiment the PLB was produced by slow pyrolysis method (Brownsort 2009). Then, the char materials were grinded using mortar and pestle and sieved through 0.5-mm sieve.
Selection of experimental plant
In the present study, gima kalmi (Ipomoea aquatica) was selected as test plant to observe the effect of PL and PLB on plant growth. Gima kalmi is a high yielding and very popular leafy vegetable. It is cultivated everywhere in Bangladesh with or without irrigation facilities throughout the year. The main benefit is that when seeds are shown once in a year, yield can be obtained throughout the year as it has regrowth capacity from its shoot (Mondal et al. 2014).
Experiment set up
Twenty-seven earthen pots (2-L) were collected and filled up with 1.5 kg pre-processed soil. The surface area of the pot was 214 cm2 and the height was 15 cm. There were four treatments for both PL and PLB along with control and three replications for each treatment. At the time of biochar production, moisture released from PL and burning at 300 °C temperature results in 60% weight reduction. The four PL treatment rates were 2.5, 5, 7.5 and 10 t ha−1 and by calculating the reduced weight of PL the four PLB treatment rates were 1, 2, 3 and 4 t ha−1, respectively, which were equivalent to the rates of PL. Fifteen days prior to seed sowing PL and PLB were mixed in the soil according to treatments and watered well for proper mixing of the PL and PLB with soil. Ten seeds of gima kalmi were sown in each pot. Ten days after seed germination, thinning was done manually leaving five healthy plants in each pot and other plants were manually removed carefully by uprooting. Irrigation was done with similar amount of water for each pot very carefully according to the need of plant to avoid root rot.
Harvesting
Six weeks after seed germination, the plants were harvested from the individual pots by cutting the stems 1 cm above the ground. After harvest, the plant height was measured using measuring scale. After washing plant shoots and air dried, plant fresh weight was taken using electric balance. The plant samples were oven dried at 70 °C for 48 h and plant dry weight was weighed with the help of electric balance.
Post-harvest soil collection for laboratory analyses
After harvest, the soil samples were collected from each pot to observe the nutrient status of soil treated with PL and PLB.
Experiment to see the residual effect of PL and PLB
After harvesting, the pots were kept fallow for one month; then gima kalmi seeds were sown again in the same pot to observe the residual effects of PL and PLB on plant growth. All the cultural practices followed were similar to the first experiment.
Analysis of different parameters
pH, EC and all other nutrient elements were determined by following the procedures described in Imamul Huq and Alam (2005).
Statistical analysis
Data were analyzed statistically following ANOVA technique using Minitab 16.0 software. Significant variations and comparisons among data were analyzed through ANOVA (Fisher’s test) and paired t test. Other calculations and graphs were prepared using Microsoft Excel 2010.
Results and discussion
Soil properties
The analytical result of some soil properties is represented in Table 1. The soil used in the experiment for plant growth is clay loam in texture, slightly acidic and very slightly saline (Soil survey manual 1993).
Properties of poultry litter and poultry litter biochar
The properties of PL and PLB are presented in Table 2. The pH values of PL and PLB were measured as 7.56 ± 0.13 and 9.05 ± 0.14, respectively, which shows 19.71% increase of pH value in PLB when PL was pyrolyzed at 300 °C. This result is in good agreement with the results of Chan et al. (2008); Cely et al. (2015); Gondek and Hersztek (2016) but opposite to Evans et al. (2017).
The OC content of PLB was also increased by 17.12% than that of PL (Table 2). Enders et al. (2012) reported that with increasing temperature, the total OC content increased while total H and O decreased during pyrolysis. Similar results were also reported by others (Chan et al. 2008; Novak et al. 2009a; Cantrell et al. 2012). High OC content of PLB helps in increasing organic matter (OM) in soil. The incorporation of 31.34% OC of PLB is equal to 54.03% OM incorporation, which helps to increase SOM and improve soil fertility (Lehmann et al. 2006).
Available N content of PL and PLB were 0.40 ± 0.03 and 0.56 ± 0.07%, respectively. Results revealed that available N content was 40% higher in PLB than PL. Experiments conducted by Chan et al. (2008); Novak et al. (2009a) at 350 °C and Evans et al. (2017) at 400 °C temperature reported that the N content increased in PLB after pyrolysis, whereas the total N content of PLB (2.04 ± 0.08) % was a little bit lower than that of PL (2.23 ± 0.14) % that means after pyrolysis at 300 °C the total N content was slightly decreased in PLB (8.52%). In this experiment, the total N content of PLB was similar to the result of Chan et al. (2008), who reported 2% total N in PLB. During pyrolysis, with the increase in pyrolysis temperature volatilization of N increases with the changes in the chemical structure of N present in biochar, ammonia and other N containing volatile organic compounds emission, etc. resulting in decrease in the total N content in biochar (Sheth and Bagchi 2005; Chan and Xu 2009; Novak et al. 2009a). But Cantrell et al. (2012) reported a different statement that the total N content in the biochar increased initially with pyrolysis at 350 °C which may be related to recalcitrant N occurring in heterocyclic compounds (Kazi et al. 2011).
Both available and total P contents in PLB were higher than that of PL (Table 2) and were increased by 59.72% and 42.25%, respectively. This result indicates that the P content in PLB was increased after producing biochar from PL. This result was in accordance with the results of Singh et al. (2010) at 300 °C and 500 °C temperature; Cantrell et al. (2012); and Evans et al. (2017). But Cely et al. (2015) revealed a different result that P concentration decreases after producing biochar, as different factors such as type of organic material, pyrolysis conditions, etc. control the properties of biochar (Mukherjee et al. 2011) and P starts to volatilize at temperatures of about 770 °C (Knoepp et al. 2005).
The available and total content of both K and Ca in PLB were estimated higher than that of PL. The available K and Ca contents were increased by 31.37% and 30.20%, respectively, and in case of total K and Ca, the rates of increase were 37.82% and 11.70%, respectively, in case of PLB. Similar result was recorded at different pyrolysis temperature and revealed that pyrolysis temperature increased the K and Ca content in PLB than PL (Cantrell et al. 2012; Cely et al. 2015; Reiter and Middleton 2016; Evans et al. 2017). But Lima et al. (2015) found a negative result that Ca content was decreased after pyrolysis of PL at 250 °C temperature.
However, due to pyrolysis of PL to PLB, a decrease in available S, Fe and Mg content was observed. Lima et al. (2015) also observed that pyrolysis decreased the S and Mg content. On the other hand, Cantrell et al. (2012) found that S, Fe and Mg contents were increased in PLB after pyrolysis. In case of total Fe and Mg content, results were slightly higher in PLB than that of PL (Table 2). Evans et al. (2017) also estimated the similar results. But Reiter and Middleton (2016) revealed a different result for Mg. In case of total S, PLB contains low S than that of PL after pyrolysis (Table 2). This result was similar to Reiter and Middleton (2016) and in contrast to the findings of Evans et al. (2017) at 400 °C.
Effects of PL and PLB on plant (gima kalmi)
Visual observations
The visual growth of gima kalmi under PL- and PLB-treated soil is presented in Fig. 1. It was observed that the growth of plants was gradually increased with the increasing rate of both PL and PLB application. The average growth (height and biomass) of plants grown under PLB application was significantly higher than that of PL application and the maximum vegetative growth was observed at 4 t ha−1 PLB application.
Plant height (cm)
To compare plant growth among different treatments, measurement of plant height is one of the major components. The average plant height at different treatments of both PL and PLB is shown in Table 3. Plant height was increased with increasing rate of both PL and PLB application. For both the cases, plant height was significantly increased in all the treatments as compared to control (Table 3). Statistical analysis of the results also revealed that in case of PL application the plant height was significantly higher at 7.5 t ha−1 (23.37 ± 1.55 cm) and 10 t ha−1 (24.12 ± 1.22 cm) PL applications (Table 3). In case of PLB application, the plant height (26.15 ± 1.28 cm) was significantly (p < 0.001) higher at 4 t ha−1 PLB application. The height of the plants treated with PLB was significantly (p = 0.024) higher than that of PL. Similar findings were also reported by Bhattarai et al. (2015) on pea by 10 t ha−1 PLB application. In a pot experiment by application of 20 g kg−1 PLB on rice plant, Maru et al. (2015) also reported the increase in plant height than control.
Plant biomass (g plant−1)
Since gima kalmi is an edible leafy vegetable, the total plant weight (shoot plus leaves) is considered as plant biomass. Both fresh and dry weights of the plants were weighed. The changes in fresh weight (FW) and dry weight (DW) in grams (g) after applying different rates of PL and PLB are presented in Table 3. Both FW and DW of the plants were significantly (p < 0.05 for FW for PL, p < 0.001 for DW for PL, p < 0.001 for both FW and DW, for PLB application) increased with the application of both PL and PLB as compared to control. FW was significantly higher at 10 t ha−1 and 4 t ha−1 PL and PLB application, respectively. Both the FW and DW of the plants treated with PLB were higher than that of PL and it was significant (p = 0.004) only for DW but insignificant (p = 0.104) for FW. The present result was advocated by Gunes et al. (2014) on lettuce where 20 g kg−1 PL and 10 g kg−1 PLB were used and observed that the plant DW was increased in the PLB-treated soil. Our results were also in good agreement with Inal et al. (2015) on maize and bean plant (highest growth observed at 10 g kg−1 PLB application). Chan et al. (2008) also reported that the yield of R. sativus was increased with the application of PLB alone. On the other hand, Allen (2014) reported a negative result on PLB application on radish yield.
Post-harvest soil analysis
Results of post-harvest soil analysis are presented in Tables 4 and 5. It was found that soil pH, EC, OC, available N, P, K, Ca, Mg, S and Fe content were increased with the increasing rate of both PL and PLB application. The OC, N, P, K, Ca and Mg of PLB-treated soil were higher than those of PL-treated soil and the highest nutritional values were also estimated at the highest rate of PLB application (4 t ha−1). The reason might be as biochar has a great ability to increase the capacity of soil to adsorb plant nutrients and decrease nutrient leaching (Liang et al. 2006; Lehmann et al. 2009; Laird et al. 2010; Steiner et al. 2010). On the other hand, S and Fe were observed higher in PL-treated soil than those of PLB-treated soil.
After harvest, there were no significant changes in the soil pH and EC treated with both PL and PLB. But an increasing effect of PLB on soil pH (Chan et al. 2008; Abbasi and Anwar 2015; Bhattarai et al. 2015) and soil EC (Chan et al. 2008) was reported in post-harvest soil analysis. Increased soil OC content was observed in higher rate of PL and PLB application as compared with initial soil OC content. Soil OC was higher in PLB-treated soils compared to PL which was also observed by Widowati et al. (2011); Abbasi and Anwar (2015); Bhattarai et al. (2015). The result indicated that biochar might be resistant to decomposition and also revealed the C storage capacity of PLB in soil (Lehman et al. 2003a; Chan et al. 2008; Lehmann and Joseph 2009). Available soil N, P and K contents showed no significant differences from its initial values though there was an increasing tendency of the elements in PLB-treated soil than that of PL-treated soil at higher rate of application. Similar results were also reported by Chan et al. (2008); Bhattarai et al. (2015); and Inal et al. (2015). The results of soil Ca and Mg content were higher after application of PLB than that of PL which were similar to the results of Chan et al. (2008) and Novak et al. (2009a). Sulfur and Fe were estimated lower in PLB-treated soil. The reasons were due to the reduction of bioavailability and water insoluble nature of S after pyrolysis. During pyrolysis under highly reducing conditions, the forms of S change, resulting in the disappearance of inorganic sulphate (Knudsen et al. 2004; Chan and Xu 2009). Novak et al. (2009b) also stated that soil bioavailability of S decreased after biochar application. Inal et al. (2015) and Maru et al. (2015) reported the similar results in case of Fe.
Residual effects of PL and PLB on plant growth
Biochar is generally popular for its distinctive properties (stability, nutrient supplier for longer period of time, carbon storage capacity, etc.). To observe the residual effects of PL and PLB on plant growth, the same plant (gima kalmi) was grown in the same pot after a one-month fallow period and the observations are given below.
Visual observations
The growth of gima kalmi was increased with the increasing rate of both PL and PLB application. But the growth was higher in case of PLB application than that of PL. The maximum growth was observed at 4 t ha−1 PLB application. The leaves were greener in color of the plants treated with PLB than that of PL-treated plants (Fig. 2). Moreover, the color of leaves in the PL-treated plants was yellowish and then turned curly in nature, which represents a sign of nutrient deficiency syndrome, especially of nitrogen (Fig. 2). Nitrogen deficiency results in a pale yellowish green colored (chlorosis) leaves, especially in the older leaves (Brady and Weil 2002). Chlorosis, restricted plant growth, etc. were observed due to N deficiency (Silas et al. 2012). So, in this experiment the PL-treated plants suffered from nitrogen deficiency. On the other hand, plant N deficiency syndrome was not prominent under PLB-treated soil. So, PLB might has the ability to absorb nutrients and release available N slowly, decrease of N loss by inhibiting NO −3 –N transformation from NH4+–N and lowering nitrogen leaching (Chan et al. 2008; Masulili et al. 2010; Widowati et al. 2011, 2012).
Plant height (cm)
The average plant height among different treatments of PL and PLB is shown in Table 6. In both the cases, plant height was increased significantly with increasing rate of application. It was observed that the plant height was significantly higher for all the treatments as compared to control plants (Table 6). Statistical analysis of the results also revealed that in case of PL application the plant height (29.82 ± 0.93 cm) was significantly (p < 0.001) higher at 10 t ha−1 PL application (Table 6), whereas in PLB application, the plant height (30.67 ± 0.36 cm) was significantly (p < 0.001) higher at 4 t ha−1 PLB application. The height of the plants treated with PLB was higher than that of PL but it was not significant (p = 0.231).
Plant biomass (g plant−1)
It was observed that both plant FW and DW were significantly increased with the increasing rate of PL and PLB application as compared to control. Both FW and DW were significantly higher at 10 t ha−1 PL and 4 t ha−1 PLB applications, respectively. The FW and DW of the plants treated with PLB was significantly (p = 0.005 for FW, p = 0.004 for DW) higher than that of PL. Similar result was also observed by Widowati et al. (2012) and reported that the height and yield of second season maize were higher than that of first season maize under PLB application.
Comparison between first and second crop treated with PL and PLB
Plant height of second crop was significantly (p = 0.021) higher than that of the first crop when it was treated with PL but it was not significant (p = 0.074) in case of PLB application (Tables 3, 6). Plant FW and DW of second crop were higher than that of the first crop in both the cases of PL and PLB. Plant FW of second crop was significantly higher (p = 0.038 for PL and p = 0.015 for PLB) than that of first crop (Tables 3, 6). Plant DW of second crop was higher than that of first crop but it was not statistically significant (p = 0.692 for PL and p = 0.428 for PLB) (Tables 3, 6). Widowati et al. (2012) reported that the height and yield of second season maize were higher than that of first season maize under PLB application.
Though the nutrient content of biochar and its effects on plant growth is an area of different opinion and controversy, numerous experiments have proven that the application of biochar helps in improving soil conditions and plant growth (Asai et al. 2009; Wisnubroto et al. 2017). In the present experiment, the most important nutrients responsible for plant growth were increased in PLB than the PL feedstock after pyrolysis. Higher yield by applying PLB might be due to its higher nutrients content. Since organic fertilizers are slow release nutrient sources, so the growth of second crop was found to be increased in both cases of PL and PLB application than that of first crop. The higher growth of the second crop under PLB-treated soil than that of PL-treated soil revealed that biochar was a stable organic amendment, resistant to microbial decomposition and with great ability to absorb and store plant nutrients than PL. This helped to decrease nutrient loss through leaching and volatilization and supplied potential nutrients slowly over time and, therefore, contributed to enhanced soil fertility and improved plant growth (Lehmann et al. 2003a, b; Steiner et al. 2007; Cheng et al. 2008; Lehmann and Joseph 2009). The growth of gima kalmi was promoted after application of PLB than application of PL in soil is clearly noticed in the present experiment. Considering all the facts PLB could be a great source of stable nutrients-rich organic amendment for plant growth.
Conclusion
Poultry litter biochar was produced from fresh PL as one of the PL management strategies and an experiment was conducted to observe the growth performance of plant treated with both PL and PLB. Thermal conversion of PL to PLB resulted in an increase of the essential nutrient content in PLB than that of PL. When PL was pyrolyzed, pH, EC and OC were increased and most of the available nutrient elements like N, P, K, Ca were increased in PLB and in case of total nutrients P, K, Ca, Mg, Fe were increased. Experimental results and visual observations revealed that plant growth (gima kalmi) was increased significantly (p < 0.001) with the increasing rate of application of PLB than that of application of PL in both cases of first and second crop. Plant height, FW and DW were higher in PLB-treated soil than that of plant grown under PL-treated soil in both cases. The highest growth of plants was observed under the highest application rate (4 t ha−1) of PLB in both first and second crop over control and other treatment rates. On the other hand, nutrient deficiency syndrome (especially N) was observed in second crop under PL-treated soil because the post-harvest soil analysis (soil was collected after the harvest of first crop) indicated that the nutrient status was lower in PL-treated soil than that of PLB-treated soil.
Though the growth of gima kalmi was also increased by PL application as it is a very good source of essential nutrients, but the growth rate of plants, especially second crop, revealed that the nutrients of PLB were more stable and had the ability to decompose slowly which results in reduction of nutrient loss and supplied available nutrients for long time and helped to improve soil fertility and plant productivity. So, from the experimental results, it is clear that PLB undoubtedly can be evaluated as a promising organic fertilizer with high nutrient content and has considerable influence on plant growth than that of fresh PL for sustainable agriculture. At the same time, making PLB from PL could be an environment friendly management strategy of PL.
References
Abbasi MK, Anwar AA (2015) Ameliorating effects of biochar derived from poultry manure and white clover residues on soil nutrient status and plant growth promotion-greenhouse experiments. PLoS One 10(6):e0131592. https://doi.org/10.1371/journal.pone.0131592
Abdullah-Al-Amin M, Rahman MS, Howlider MAR, Ahmmed MM (2009) Disposal of layer droppings reared in case and impact on environmental pollution. J Bangladesh Agril Univ 7(2):281–290. https://doi.org/10.3329/jbau.v7i2.4735
Adhami E, Hosseini S, Owliaie H (2014) Forms of phosphorus of vermicompost produced from leaf compost and sheep dung enriched with rock phosphate. Int J Recycl Org Waste Agricult 3:68. https://doi.org/10.1007/s40093-014-0068-9
Akanni KA, Benson OB (2014) Poultry wastes management strategies and environmental implications on human health in Ogun state of Nigeria. Adv Econ Bus 2(4):164–171. https://doi.org/10.13189/aeb.2014.020402
Ali K, Arif M, Shah F, Shehzad A, Munsif F, Mian IA, Mian AA (2017) Improvement in maize (Zea mays L) growth and quality through integrated use of biochar. Pak J Bot 49(1):85–94
Allen JM (2014) The effects of poultry litter biochar and water source on radish growth and nutrition. Crop, Soil and Environmental Sciences. Undergraduate Honors Theses-9, pp. 3-4. University of Arkansas, Fayetteville. http://scholarworks.uark.edu/csesuht/9. Accessed 24 January 2018
Asai H, Samson BK, Stephan HM, Songyikhangsuthor K, Homma K, Kiyono Y, Inoue Y, Shiraiwa T, Horie T (2009) Biochar amendment techniques for upland rice production in Northern Laos 1. Soil physical properties, leaf SPAD and grain yield. Field Crops Res 111:81–84. https://doi.org/10.1016/j.fcr.2008.10.008
AWMFH (Agricultural Waste Management Field Handbook) (2013) Resources for planning and designing animal waste facilities, 210-I-AWMFH–AMENDMENT IA-3. Siting criteria for vegetative treatment systems, Section 4
Baldock JA, Smernik RJ (2002) Chemical composition and bioavailability of thermally altered Pinus Resinosa (red pine) wood. Org Geochem 33:1093–1109
Bhattarai B, Neupane J, Dhakal SP, Nepal J, Gnyawali B, Timalsina R, Poudel A (2015) Effect of biochar from different origin on physio-chemical properties of soil and yield of garden pea (Pisum sativum L.) at Paklihawa, Rupandehi, Nepal. World J Agric Res 3(4):129–138. https://doi.org/10.12691/wjar-3-4-3
Bolan NS, Szogi AA, Chuasavathi T, Seshadri B, Rothrock MJJ, Panneerselvam P (2010) Uses and management of poultry litter. Worlds Poult Sci J 66:673–698. https://doi.org/10.1017/s0043933910000656
Brady NC, Weil RR (2002) The nature and properties of soils.13th edition. Pearson Education (Singapore) Private Limited, Indian Branch, Delhi. ISBN 81-7808-625-5
Brownsort PA (2009) Biomass pyrolysis processes: performance parameters and their influence on biochar system benefits. Edinburgh: UK Biochar Research Centre - SCCS Consortium. A dissertation presented for the degree of Master of Science University of Edinburgh
Bruun EW (2011) Application of fast pyrolysis biochar to a loamy soil- effects on carbon and nitrogen dynamics and potential for carbon sequestration. Riso-PhD-78 (EN). Information Service Department Riso, National Laboratory for Sustainable Energy. Technical University of Denmark. ISBN 978-87-550-3910-0
Cantrell KB, Hunt PG, Uchimiya M, Novak JM, Ro KS (2012) Impact of pyrolysis temperature and manure source on physicochemical characteristics of biochar. Bioresour Technol 107:419–428. https://doi.org/10.1016/j.biortech.2011.11.084
Cely P, Gascó G, Paz-Ferreiro J, Méndez A (2015) Agronomic properties of biochars from different manure wastes. J Anal Appl Pyrolysis 111:173–182. https://doi.org/10.1016/j.jaap.2014.11.014
Chan KY, Xu Z (2009) Biochar: nutrient properties and their enhancement. pp. 67-84. In: Lehmann J, Joseph S (eds) Biochar for environmental management: science and technology. Earthscan, London. ISBN: 978-1-84407-658-1
Chan KY, Van Zwieten L, Meszaros I, Downie A, Joseph S (2007a) Assessing the agronomic values of contrasting char materials on Australian hard setting soil. Proceedings of the Conference of the International Agrichar Initiative (IAI), 27 April - 2 May 2007, Terrigal, NSW, Australia
Chan KY, Van Zwieten L, Meszaros I, Downie A, Joseph S (2007b) Agronomic values of green waste biochar as a soil amendment. Aust J Soil Res 45:629–634. https://doi.org/10.1071/sr07109
Chan KY, Dorahy CG, Tyler S, Wells AT, Milham PP, Barchia I (2007c) Phosphorus accumulation and other changes in soil properties as a consequence of vegetable production in the Sydney region, New South Wales, Australia. Aust J Soil Res 45:139–146. https://doi.org/10.1071/sr06079
Chan KY, Van Zwieten L, Meszaros I, Downie D, Joseph S (2008) Using poultry litter biochars as soil amendments. Aust J Soil Res 46:437–444. https://doi.org/10.1071/sr08036
Cheng CH, Lehmann J, Thies JE, Burton SD (2008) Stability of black carbon in soils across a climatic gradient. J Geophys Res 113:G02027. https://doi.org/10.1029/2007jg000642
Covell P, Gammie G, Hunt S, Brunjes L, Ng F, Nees D (2011) Advancing biochar in the chesapeake: a strategy to reduce pollution from poultry litter-forest trends/katoomba incubator, carbon war room, forest trends/chesapeake fund. https://www.forest-trends.org/wp-content/uploads/imported/Report_Final.pdf. Accessed 3 January 2018
Dikinya O, Mufwanzala N (2010) Chicken manure enhanced soil fertility and productivity: Effects of application rates. J Soil Sci Environ Manage 1(3):46-54. ISSN 2141-2391
Draper K, Tomlinson T (2012) Poultry litter biochar- a US perspective. International Biochar Initiative (IBI). http://www.biochar-international.org/sites/default/files/Poultry_litter_final_2012.pdf. Accessed 25 February 2018
Enders A, Hanley K, Whitman T, Joseph S, Lehmann J (2012) Characterization of biochars to evaluate recalcitrance and agronomic performance. Bioresour Technol 114:644–653. https://doi.org/10.1016/j.biortech.2012.03.022
Evans MR, Jackson BE, Popp M, Sadaka S (2017) Chemical properties of biochar materials manufactured from agricultural products common to the Southeast United States. Horttechnology 27(1):16–23. https://doi.org/10.21273/horttech03481-16
FAO (2006) World agriculture: towards 2030/2050. Interim report. Food and Agriculture Organization of the United Nations. Prospects for food, nutrition, agriculture and major commodity groups, Rome
Foreman P, Long C (2013) Chickens in the garden: eggs, meat, chicken manure fertilizer and more. Ogden Publications, Inc., 1503 SW 42nd St., Topeka, Kansas 66609-1265
FRG (2012) Fertilizer recommendation guide, Bangladesh agricultural research council (BARC), Farmgate, Dhaka 1215, pp 1-274. ISBN: 978-984-500-000-0
Gaskin JW, Steiner C, Harris K, Das KC, Bibens B (2008) Effect of low temperature pyrolysis conditions on biochar for agricultural use. T ASABE 51(6):2061–2069. https://doi.org/10.13031/2013.25409
Gondek K, Hersztek MM (2016) Effect of thermal conversion of pig manure and poultry litter on the content and mobility of Mn and Fe in biochars and in soil after their application. CHILENJAR. J Agric Res 73(3):349–355. https://doi.org/10.4067/s0718-58392016000300013
Gruhn P, Golett F, Yudelman M (2000) Integrated nutrient management, soil fertility and sustainable agriculture: Current issues and future challenges. Food, agriculture and environment discussion, Paper 32. International Food Policy Research Institute, Washington DC, USA, pp. 1-3, ISBN 0-89629-638-5
Gunes A, Inal A, Taskin MB, Sahin O, Kaya EC, Atakol A (2014) Effect of phosphorus-enriched biochar and poultry manure on growth and mineral composition of lettuce (Lactuca sativa L. cv.) grown in alkaline soil. Soil Use Manag 30:182–188. https://doi.org/10.1111/sum.12114
Imamul Huq SM, Alam MD (eds) (2005) A handbook on analysis of soil, plant and water. BACER-DU, University of Dhaka, Banglaesh. ISBN-984-32-1770-5
Inal A, Gunes A, Sahin O, Taskin MB, Kaya EC (2015) Impacts of biochar and processed poultry manure, applied to a calcareous soil, on the growth of bean and maize. Soil Use Manag 31(1):106–113. https://doi.org/10.1111/sum.12162
Islam MK, Uddin MF, Alam MM (2014) Challenges and prospects of poultry industry in Bangladesh. Eur J Bus Manag 6(7):116–127
Islami T, Guritno B, Basuki N, Suryanto A (2011) Biochar for sustaining productivity of cassava based cropping systems in the degraded lands of East Java, Indonesia. J Trop Agric 49(1–2):40–46
Jenkinson DS, Adams DE, Wild A (1991) Model estimate of CO2 from soil in response to global warming. Nature 351:304–306. https://doi.org/10.1038/351304a0
Joardar JC, Rahman MM (2018) Poultry feather waste management and effects on plant growth. Int J Recycl Org Waste Agric. https://doi.org/10.1007/s40093-018-0204-z
Karim Z, Iqbal A (2001) Impact of land degradation in Bangladesh: changing scenario in agricultural land use. Bangladesh Agricultural Research Council. Soils publication, issue- 42. Farm Gate. Dhaka pp. 60-160
Kazi ZH, Schnitzer MI, Monreal C, Mayer P (2011) Separation and identification of heterocyclic nitrogen compounds in bio-oil derived by fast pyrolysis of chicken manure. J Environ Sci Health B 46:51–61. https://doi.org/10.1080/03601234.2010.515506
Knoepp JD, DeBano LF, Neary DG (2005) Soil Chemistry. Chapter: 3. In: Neary DG, Ryan KC, DeBano LF (eds) Wildland fire in ecosystems: effects of fire on soils and water. Gen. Tech. Rep. RMRS-GTR 42-vol. 4, Ogden, UT: US Department of Agriculture, Forest Service, Rocky Mountain Research Station, pp. 53-71
Knudsen JN, Jensen PA, Lin W, Frandsen FJ, Dam-Johnson K (2004) Sulfur transformations during thermal conversion of herbaceous biomass. Energ Fuel 18(3):810–819. https://doi.org/10.1021/ef034085b
Laird DA, Fleming P, Davis DD, Horton R, Wang BQ, Karlen DL (2010) Impact of biochar amendments on the quality of a typical Midwestern agricultural soil. Geoderma 158:436–442. https://doi.org/10.1016/j.geoderma.2010.05.012
Lehmann J (2009) Terra Preta Nova- where to from here? chapter 28. In: Woods WI, Teixeira WG, Lehmann J, Steiner C, WinklerPrins AMGA, Rebellato L et al (eds) Amazonian dark earths Wim Sombroek’s Vision. Springer, Dordrecht
Lehmann J, Joseph S (2009) Biochar for environmental management: an introduction. In: Lehmann J, Joseph S (eds) Biochar for environmental management: science and technology. Earthscan, London, pp 1–9 978-1-84407-658-1
Lehmann J, da Silva JP, Jr Steiner C, Nehls T, Zech W, Glaser B (2003a) Nutrient availability and leaching in an archaeological anthrosol and a ferralsol of the central amazon basin: fertilizer, manure and charcoal amendments. Plant Soil 249:343–357
Lehmann J, Kern DC, German LA, McCann J, Martins GC, Moreira A (2003b) Soil fertility and production potential. In: Lehmann J, Kern DC, Glaser B, Woods WI (eds) Amazonian dark earths: origin, properties and management. Kluwer, Dordrecht, pp 105–124
Lehmann J, Gaunt J, Rondon M (2006) Biochar sequestration in terrestrial ecosystems–a review. Mitig Adapt Strat Gl 11:403–427. https://doi.org/10.1007/s11027-005-9006-5
Lehmann J, Czimczik C, Laird D, Sohi S (2009) Stability of biochar in soil. In: Lehmann J, Joseph S (eds) Biochar for Environmental Management: Science and Technology. Earthscan, London, pp 183–205 978-1-84407-658-1
Liang B, Lehmann J, Solomon D, Kinyangi J, Grossman J, O’Neill B, Skjemstad JO, Thies J, Luizão FJ, Petersen J, Neves EG (2006) Black carbon increases cation exchange capacity in soils. Soil Sci Soc Am J 70:1719–1730. https://doi.org/10.2136/sssaj2005.0383
Lima IM, Kyoung SR, Reddy GB, Boykin DL, Klasson KT (2015) Efficacy of chicken litter and wood biochars and their activated counterparts in heavy metal clean up from wastewater. Agriculture 5(3):806–825. https://doi.org/10.3390/agriculture5030806
MacLeod M, Gerber P, Mottet A, Tempio G, Falcucci A, Opio C, Vellinga T, Steinfeld H, Henderson B (2013) Greenhouse gas emissions from pig and chicken supply chains-a global life cycle assessment. Food and Agriculture Organization of the United Nations (FAO), Rome
Maru A, Haruna OA, Primus WC (2015) Coapplication of chicken litter biochar and urea only to improve nutrients use efficiency and yield of Oryza sativa L. cultivation on a tropical acid soil. Sci World J. https://doi.org/10.1155/2015/943853
Masulili A, Utomo WH, Ms S (2010) Rice husk biochar for rice based cropping system in acid soil 1. The characteristics of rice husk biochar and its influence on the properties of acid sulfate soils and rice growth in West Kalimantan, Indonesia. J Agric Sci (Canada) 3:25–33. https://doi.org/10.5539/jas.v2n1p39
Mondal MRI, Sultan MK, Nur S, Sarkar MJU, Alam MS, Rahman MHH (2014) Krishi Proyukti Hatboi (Handbook of agro-technology), 6th edn. Bangladesh agricultural Research institute, Gazipur, p 1701
Mukherjee A, Zimmerman AR, Harris W (2011) Surface chemistry variations among a series of laboratory-produced biochars. Geoderma 163:247–255. https://doi.org/10.1016/j.geoderma.2011.04.021
Nair VD, Nair PKR, Dari B, Freitas AM, Chatterjee N, Pinheiro FM (2017) Biochar in the agroecosystem–climate-change–sustainability nexus. Front Plant Sci 8:2051. https://doi.org/10.3389/fpls.2017.02051
Novak JM, Busscher WJ, Laird DL, Ahmedna M, Watts DW, Niandou MAS (2009a) Impact of biochar amendment on fertility of a southeastern coastal plain soil. Soil Sci 174(2):105–112. https://doi.org/10.1097/ss.0b013e3181981d9a
Novak JM, Lima I, Xing B, Gaskin JW, Steiner C, Das KC, Ahmedna M, Rehrah D, Watts DW, Busscher WJ, Schomberg H (2009b) Characterization of designer biochar produced at different temperatures and their effects on a loamy sand. Ann Environ Sci 3:195–206
O’Neill DH, Phillips VR (1992) A review of the control of odour nuisance from livestock buildings: part 3, properties of the odorous substances which have been identified in livestock wastes or in the air around them. J Agric Eng Res 53:23–50. https://doi.org/10.1016/0021-8634(92)80072-Z
Oshunsanya SO, Aliku OO (2016) Biochar technology for sustainable organic farming. In: Konvalina P (ed) Organic farming-a promising way of food production Agricultural and Biological Sciences. In Tech, The Hague
Reddy KC, Reddy SS, Malik RK, Lemunyon JL, Reeves DW (2008) Effect of five-year continuous poultry litter use in cotton production on major soil nutrients. Agron J 100(4):1047–1055. https://doi.org/10.2134/agronj2007.0294
Reiter MS, Middleton A (2016) Nutrient availability from poultry litter co-products. A summary of findings funded by the Farm Manure-to-Energy Initiative, Appendix F
Sarkar SKM, Sadeka S, Sikdar MHM, Badiuzzaman (2015) Energy consumption and CO2 emission in Bangladesh: trends and policy implications. Asia Pac J Energy Environ 2(3):175–182
Schilke-Gartley KL, Sims JT (1993) Ammonia volatilization from poultry manure-amended soil. Biol Fertil Soils 16(1):5–10. https://doi.org/10.1007/BF00336507
Scholz SM, Sembres T, Roberts K, Whitman T, Wilson K, Lehmann J (2014) Biochar systems for small holders in developing countries leveraging current knowledge and exploring future potential for climate-smart agriculture. The World Bank, Washington 10.1596/978-0-8213-9525-7
Sheth AC, Bagchi B (2005) Investigation of nitrogen-bearing species in catalytic steam gasification of poultry litter. J Air Waste Manag Assoc 55:619–628. https://doi.org/10.1080/10473289.2005.10464653
Shinogi Y (2004) Nutrient leaching from carbon products of sludge. In ‘ASAE Annual International Meeting’. Paper No. 044063, Ottawa, Ontario, Canada. pp 4951-4960
Silas NE, Murungi JI, Wanjau RN (2012) Levels of macronutrients of leaves of selected plants from highlands east of Mount Kenya. Int J Appl Sci Technol 2(9):105–110
Singh K, Risse LM, Das KC, Worley J, Thompson S (2010) Effect of fractionation and pyrolysis on fuel properties of poultry litter. J Air Waste Manag Assoc 60(7):875–883. https://doi.org/10.3155/1047-3289.60.7.875
Sohi S, Lopez-Capel E, Krull E, Bol R (2009) Biochar, climate change and soil: a review to guide future research. CSIRO Land and Water Science Report 05/09. ISSN: 1834-6618
Soil survey manual (1993) Soil survey division staff, chapter 3 Soil conservation service. US Department of Agriculture, Washington, DC
Steiner C, Teixeira WG, Lehmann J, Nehls T, de Macedo JLV, Blum WEH, Zech W (2007) Long-term effects of manure, charcoal and mineral fertilization on crop production and fertility on a highly weathered central Amazonian upland soil. Plant Soil 291(1–2):275–290. https://doi.org/10.1007/s11104-007-9193-9
Steiner C, Das KC, Nathan M, Donald L (2010) Reducing nitrogen loss during poultry litter composting using biochar. J Environ Qual 39(4):1236–1242. https://doi.org/10.2134/jeq2009.0337
Thies JE, Rillig MC (2009) Characteristics of biochar: biological properties. In: Lehmann J, Joseph S (eds) Biochar for environmental management science and technology. Earthscan, London, pp 85–95. ISBN 978-1-84407-658-1
USDA (1951) Soil survey manual. Soil survey staff, bureau of plant industry, soil and agricultural engineering. US Depart Agriculture (USDA), Washington
Usman M, Madu VU, Alkali G (2015) The combined use of organic and inorganic fertilizers for improving maize crop productivity in Nigeria. Int J Sci Res Pub 5(10):1–7 (ISSN 2250-3153)
Verheijen F, Jeffery S, Bastos AC, vander Velde M, Diafas I (2010) Biochar application to soils—a critical scientific review of effects on soil properties, processes and functions. EUR 24099 EN, Office for the Official Publications of the European Communities, Luxembourg, 149 pp. ISBN 978-92-79-14293-2. https://doi.org/10.2788/472
Vijayanand C, Kamaraj S, Sriramajayam S, Ramesh D (2016) Biochar production from arecanut waste. Int J Farm Sci 6(1):43–48
Warman PR (1986) The effect of fertilizer, chicken manure and dairy manure on timothy yield, tissue composition and soil fertility. Agric Wastes 18(4):289–298. https://doi.org/10.1016/0141-4607(86)90074-0
Widowati Utomo WH, Soehono LA, Guritno B (2011) Effect of biochar on the release and loss of nitrogen from urea fertilization. J Agric Food Technol 1(7):127–132
Widowati Utomo WH, Guritno B, Soehono LA (2012) The effect of biochar on the growth and N fertilizer requirement of Maize (Zea mays L) in green house experiment. J Agric Sci 4(5):255–262. https://doi.org/10.5539/jas.v4n5p255
Wisnubroto EI, Utomo WH, Soelistyari HT (2017) Biochar as a carrier for nitrogen plant nutrition the release of nitrogen from biochar enriched with ammonium sulfate and nitrate acid. Int J Appl Eng Res 12(6):1035–1042 (ISSN 0973-4562)
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors would like to declare that there is no conflict of interest with this research.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made.
About this article
Cite this article
Sikder, S., Joardar, J.C. Biochar production from poultry litter as management approach and effects on plant growth. Int J Recycl Org Waste Agricult 8, 47–58 (2019). https://doi.org/10.1007/s40093-018-0227-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40093-018-0227-5